General Maintenance; Initial Break-In Maintenance; 10 Hour Or Daily Routine Maintenance - Ingersoll Rand BX-60WH Manual De Utilización Y Mantenimiento

GENERAL MAINTENANCE

1. Engine RPM is adjusted to: 3,600 rpm (With load).
2. Check Bolts and Nuts for looseness. Tighten it if necessary.
3. Check for fuel and oil leak.
4. Keep the RUBBER BUFFER away from oil and fuel.
5. Check the V-Belt for wear, damage and cracks. If necessary,
replace with a new belt.
6. Please refer to "Owners Manual" for HONDA engine
GX120K1 (BX-60WH) or GX160K1 (BX-80WH/BX-120WH)
for maintenace instructions for the engine on your machine.
7. Keep the air cleaner element clean. See "10 HOUR OR
DAILY ROUTINE MAINTENANCE".

INITIAL BREAK-IN MAINTENANCE

Engine Oil
Drain the engine oil after the first 20 hours of operation. Fill with
the correct amount of the recommended oil. Check the oil level
with the oil filler cap/dip stick. See "50 HOUR OR WEEKLY
ROUTINE MAINTENANCE".
WARNING
Hot oil and/or components can burn.
Oil must be at normal operating temperature when
draining. Avoid contact with hot oil or components.
Lubrication
Lubrication is an essential part of preventive maintenance,
affecting to a great extent the useful life of the unit. Different
lubricants are needed and some components in the unit require
more frequent lubrication than others.
Specific recommendations of brand and grade of lubricants are
not made here due to regional availability, operating conditions,
and the continual development of improved products. Where
questions arise, refer to the requirements and specifications in
the manufacturer's manual.
All oil levels are to be checked with the machine parked on a
level surface, and while the oil is cold, unless otherwise
specified.
Check Fuel
1. Stop the engine and open the fuel tank cap.
2. Use the automobile unleaded gasoline only.
3. Close the fuel cock before filling the fuel tank.
4. When filling the fuel tank, always use the fuel filter.
5. Wipe off any spilled fuel before starting the engine.
Fuel is flammable. May cause injury and property damage.
Shut down the engine, extinguish all open flames and do
not smoke while filling the fuel tank.
Always wipe up any spilled fuel.

10 HOUR OR DAILY ROUTINE MAINTENANCE

It is recommended that the following steps be performed at the
beginning and end of each 8 to 10 hour shift or daily, whichever
comes first.
Engine Oil
Check the engine's oil level at the start of each day and
maintain it to the full mark on the dipstick. Insert the dipstick and
check the full mark on the dipstick. See "50 HOUR OR WEEKLY
ROUTINE MAINTENANCE".
Air Cleaner
If the machine is operating in a dusty environment check the air
cleaner daily. Keep the Air Cleaner Element clean.
Never use gasoline or low flash point solvents to clean the
filter. a fire or explosion may result.
To clean the Air Cleaner:
1. Remove the wing nut ( , [Figure 8]) and air cleaner cover
Figure 8
BX-60WH / BX-80WH / BX-120WH Plate Compactors
10-EN
WARNING
WARNING
Operation & Maintenance Manual
.