Tabla De Contenido; Products Covered By This Manual; Manual Contents; Introduction - Allmand MAXI-LITE Manual Del Operario

Products Covered by This
Manual
The following products are covered by this manual:
®
Maxi-Lite

Manual Contents:

Introduction........................................................................... 2
Safety......................................................................................2
Features And Controls......................................................... 7
Pre-Operation Checklist....................................................... 9
Transporting........................................................................ 10
Operation............................................................................. 15
Maintenance.........................................................................21
Troubleshooting.................................................................. 26
Specifications...................................................................... 26
WARNING
Breathing diesel engine exhaust exposes you to chemicals
known to the State of California to cause cancer and birth
defects or other reproductive harm.
• Always start and operate the engine in a well-ventilated
area.
• If in an enclosed area, vent the exhaust to the outside.
• Do not modify or tamper with the exhaust system.
• Do not idle the engine except as necessary.
For more information go to www.P65Warnings.ca.gov/
diesel.

Introduction

About This Manual
TAKE TIME TO READ THIS MANUAL THOROUGHLY
This instruction manual provides necessary instructions for
® ®
the Allmand Maxi-Lite Light Tower.
The information found in this manual is in effect at the time
of printing. Allmand Bros Inc. may change contents without
notice and without incurring obligation.
The images throughout this manual are representative, and
may differ from your model.
Any reference in this manual to left or right shall be
determined by looking at the trailer from the rear.
If uncertain about any of the information in the
manual, contact the Allmand service department at
1-800-562-1373, or contact us through the Allmand website,
www.allmand.com.
Save these original instructions for future reference.
2

Safety

Safety Definitions

For your safety, the safety of others, and to protect the
performance of equipment, follow the precautions listed
throughout the manual before operation, during operation and
during periodic maintenance procedures.
Indicates a potential personal injury hazard.
DANGER
Indicates a hazardous situation which, if not avoided, will
result in death or serious injury.
WARNING
Indicates a hazardous situation which, if not avoided, could
result in death or serious injury.
CAUTION
Indicates a hazardous situation which, if not avoided, could
result in minor or moderate injury.
NOTICE
Information considered important but not hazard related.
Safety Precautions
The following section contains general safety precautions
and guidelines that must be obeyed to reduce risk to
personal safety. Special safety precautions are listed in
specific procedures. Read and understand all of the safety
precautions before operating or performing repairs or
maintenance.
DANGER
Electrocution Hazard
• Always check overhead wires and obstructions before
raising or lowering the light tower.
• Always obey the rules or instructions for your work
site and state, province and national electric code for
maintaining a safe distance from overhead wires.
• High voltage is present when engine is running. Never
attempt to service electrical components while engine is
running.
• Do not operate the light tower if the insulation on the
electrical cord or other electrical wiring is cut or worn or
if bare wires are exposed. Repair or replace damaged
wiring before starting the engine.