Spraying Precautions - MADER LJ1500-24 Manual Del Usuario

2. Follow all local electrical and safety codes.
3. Only persons well acquainted with these rules
of safe operation should be allowed to use the
compressor.
4. Keep visitors away and NEVER allow
children in the work area.
5. Wear safety glasses
and use hearing
protection when
operating the pump or
unit.
6. Do not stand on or
use the pump or unit as a handhold.
7. Before each use, inspect compressed air
system and electrical components for signs of
damage, deterioration, weakness or leakage,
Repair or replace defective items before using.
8. Check all fasteners at frequent intervals for
proper tightness.
▲WARNING!
equipment and controls
can cause electrical arcs
that will ignite
flammable gas or vapor,
never operate or repair
in or near a flammable gas or vapor, never store
flammable liquids or gases in the vicinity of the
compressor.
▲CAUTION!
Compressor parts may
be hot even if the unit is
stopped.
9. Keep fingers away
compressor, fast moving and hot parts will cause
injury and/or burns.
10. If the equipment should start to abnormally
vibrate, STOP the engine/motor and check
immediately for the cause, vibration is generally
a warning of trouble.
11. To reduce fire hazard, keep engine/motor
exterior free of oil, solvent, or excessive grease.
Motors, electrical
a
from a running
▲WARNING!
attempt to adjust safety valve. Keep safety valve
free from paint and other accumulations.
▲DANGER!
Never attempt to repair
or modify a tank!
Welding, drilling or any
other modification will
weaken the tank resulting in damage from
rupture or explosion. Always replace worn or
damaged tanks.
▲WARNING! Drain liquid from tank daily.
13.Tanks rust from moisture build-up, which
weakens the tank. Make sure to drain tank
regularly and inspect periodically for unsafe
conditions such as rust formation and corrosion.
14.Fast moving air will stir up dust and debris,
which may be harmful. Release air slowly when
draining moisture
compressor system.

SPRAYING PRECAUTIONS

▲WARNING!
Do not spray flammable
materials in vicinity of
open flame or
ignition sources including the compressor unit.
15.Do not smoke
insecticides, or other flammable substances.
16.Use a face
mask/respirator when
spraying and spray in a
well-ventilated area to
prevent health and fire
hazards.
17.Do not direct paint or other sprayed material at
the compressor. Locate compressor as far away
from the spraying area as possible to minimize
2
Never remove or
or depressurizing
near
when spraying paint,
the