Troubleshooting - BUTSIR ATRIO Manual De Instrucciones

TROUBLESHOOTING

PROBLEM
Burner won't
light
Burner won't
stay lit
Burner flame
is low
Note: Do
not operate
appliance
below 5 ˚C
Carbon build-
up
Flash back
(flame inside
burner)
Thick black
smoke
If you cannot solve the problems according to one of the solutions mentioned, please contact us
through our website: www.butsir.com, write an email to comercial@butsir.com, phone: +34 936
620 680 or contact your dealer or distributor.
Manual ATRIO.indd 27
CONDITION
Control knob is not in Maximum
position (big flame).
LPG cylinder valve is closed /
Empty.
Blockage in the injector.
Air in the gas circuit.
Low gas pressure.
Igniter fails.
Dirty build up around burner.
Low flames or not full running
around the burner.
Thermocouple is not operating
correctly.
Low Gas pressure.
Outdoor temperature is greater
than 5 ˚C and LPG cylinder is less
than 25 % full.
Gas pipe is bent or kinked.
Control knob is fully Maximum
position (big flame).
Dirty or film on burner.
Burner ports are blocked.
Blockage in the burner.
SOLUTION SUGGESTED
Turn control knob in Maximum position (big
flame).
Open the valve / Replace LPG cylinder with
a new one.
Clean or replace injector.
Open gas line and bleed it (pressing control
knob in) for not over 1 minute or until you
smell gas.
Replace LPG cylinder with a new one.
Use match to light burner; change battery
or obtain new ignite and replace
Clean dirty around the burner.
Flame spreader holes partially closed; clean
the burner.
Replace thermocouple (FSD).
Replace LPG cylinder with a new one.
Replace LPG cylinder with a new one.
Straighten hose and perform leakage test
on gas pipe.
Turn control knob to"OFF" position (full disk),
let cool to room temperature and check
burner and orifices for blockage.
Clean burner.
Switch OFF the appliance. Close LPG
cylinder valve. Wait 2 minutes, following the
ignition procedure. Ignite burner. If problem
continuous, switch-off. Contact your dealer.
Turn control knob to "OFF" position, let the
appliance to cool at room temperature and
remove blockage and clean burner inside
and outside.
it.
27
30/4/21 13:29