Tabla de contenido
Publicidad
Idiomas disponibles
Idiomas disponibles
and locknut holding the safety hooks. There should be at least
one visible thread on the bolt beyond the locknut.
3)
Inspect anchor hooks for cracks and deformation. Check that
the safety clasps are functional.
4)
Check end play by pulling and pushing the capstan drum. A
small movement is normal, more than 0.5 mm indicates the
drum retaining screw could be loose or the washer damaged.
5)
Check drum keyway by turning the drum back and forth. A
small movement is acceptable and indicates proper gear
backlash. Large movement may indicate wear of the keyway; if
so remove end screw and inspect.
6)
Check that rope entry pulley (brass pulley) is rotating freely; if
not clean and lubricate. Replace pulley if any flat spots are present.
7)
Rope Grabbing System: Check that plate is pivoting freely and
that there is no excessive wear on the pivot surfaces. Check if
pivot bolt is tight.
8)
Look at casting for cracks, particularly in the anchoring region.
9)
Remove engine from the gearbox by removing the 6 bolts.
a.
Inspect clutch rotor (engine side) for:
i.
Cracks;
ii.
Loose screws;
iii.
Uneven wear or other damage.
b.
Inspect clutch drum (gearbox side) for:
i.
Wear: minimum thickness: 2 mm (0.080");
ii.
Tightness: no noticeable axial movement;
iii.
Bearing condition: turns evenly and smoothly by hand.
4.4.2
Engine
(PCH1000 and PCH2000 only)
1)
Clean/adjust spark plug;
2)
Check/adjust idle speed;
3)
Check/adjust valve clearance;
4)
Clean fuel tank and filter;
5)
Clean spark arrestor if equipped.
a.
NOTE: These items should be serviced by your Honda
servicing dealer, unless you have the proper tools and are
mechanically proficient. Refer to the Honda shop manual for
service procedures.
4.5
General winch condition
Make an assessment of the general winch condition in a clear
manner such as Excellent, Good, Needs Repairs, Requires Further
Evaluation, etc.
4.6
Winches not in regular service
1)
A winch which has not been used for more than one
month, but less than six months, shall be given a Frequent
Inspection before being put in service.
2)
A winch which has not been used for more than six months
shall be given a Periodic Inspection prior to being put in service.
5.
Complementary information
5.1
Accessories
A complete line of accessories is available. Simply visit
www.portablewinch.com
5.2
Warranty
Portable Winch Co. products are warranted against defects in
materials and workmanship while owned by the "original purchaser".
The "original purchaser" is defined as the party or entity which
purchases the winch and/or accessories from an authorized Portable
Winch Co. retailer as shown by the original invoice.
The warranty ownership is transferable, provided the
end-user has a copy of the original purchaser's invoice.
This warranty does not apply to "wear parts" defined as being in
contact with the rope while winching.
The PCH1000, PCH2000 and PCT1800 Portable Capstan
Pulling/Lifting WinchTM are covered as follow:
Winch components:
●
Private use: Two (2) year warranty (service by Portable Winch Co.
and/or its retailers);
Commercial use: One (1) year warranty (service by Portable Winch
Co. and/or its retailers);
●
PCH1000 and PCH2000: The Honda engine is warranted by
Honda Motor Corporation and the duration varies according to
country and usage. All Honda service centers can repair the
winch engine under warranty. Hang on to your proof of purchase
(original invoice with serial number). It will be used to establish
the beginning of the warranty period.
●
PCT1800: The Baldor motor is warranted by Baldor and the
duration varies according to country and usage. All Baldor service
centers can repair the winch motor under warranty. Hang on to
your proof of purchase (invoice with serial number). It will be used
to establish the beginning of the warranty period.
Portable Winch Co. will replace or repair, at its option, any defective
product. All other Portable Winch
complete one (1) year warranty. Please refer to the Portable Winch
Co. warranty policies on
www.portablewinch.com
questions.
Extend your warranty for free
We would like to thank you for your purchase. By doing so we would
like to offer you ONE (1) EXTRA YEAR WARRANTY for FREE! It's
simple, simply register your winch on
phone at 1-888-388-PULL (7855) or +1 819 563-2193.
5.3
Trouble shooting
In case of unexpected issues, visit the Trouble shooting page on
www.portablewinch.com, page Manuals and Instructions.
5.4
Exploded view and parts list
To obtain exploded views and part lists, visit the Exploded views
page on www.portablewinch.com, page Manuals and Instructions.
EN
TM
accessories are covered by a
if you have any
www.portablewinch.com
or by
11
Publicidad
Tabla de contenido
