IBEA IB-G5800 Manual Del Usuario página 26

7.2.1 PERIODIC MAINTENANCE TABLE:
EVERY 8 HOURS
MAINTENANCE ITEMS EVERY 20 HOURS
(DAILY)
CLEAN GENERTOR AND
X
CHECK BOLTS AND NUTS
CHECK AND REFILL ENGINE
X
OIL
REPLACE ENGINE OIL INITIAL
CLEAN SPARK PLUG
CLEAN AIR FILTER
REPLACE AIR FILTER
ELEMENT
CLEAN FUEL STRAINER
CLEAN AND ADJUST SPARK
PLUG AND ELECTRODES
REPLACE SPARK PLUG
REMOVE CARBON FROM
CYLINDER HEAD
CLEAN AND ADJUST VALVE
CLERANCE
CLEAN AND ADJUST
CARBURETOR
CLEAN AND REPLACE
CARBON BRUSHES
REPLACE FUEL LINES
OVERHAUL ENGINE
*Note: The initial oil change should be performed after the rst twenty (20) hours of
operation thereafter only change the oil every one hundred (100) hours.
7.2.2. Before changing the oil, please try to look for a suitable way to dispose of old oil.
7.2.3. Do not pour it down drains, onto garden soil or into open streams. Follow your
local zoning or environment instructions on proper disposal.
50
EVERY 100 HOURS EVERY 200 HOURS EVERY 500 EVERY 1000
(WEEKLY) (MONTHLY) HOURS HOURS
EVERY 100 HOURS
X
X
X
X
X
X
X
X
X
IF AND WHEN REQUIRED
8. "HOW TO CONDUCT" MAINTENANCE:
8.1. ENGINE OIL CHANGE:
We recommend that you change the engine oil every 100
hours (For a new engine please change the engine oil
after the rst 20 hours).
OIL CAPACITY:
IB-G5800 - 1,1 L
IB-G6500ET - 1,1 L
8.1.1. Drain the oil by removing the drain plug and the oil ller cap while the engine is
still warm.
8.1.2. Once the oil has completely drained out reinstall the drain plug and ll the engine
with oil until it reaches the upper level on the oil ller cap. DO NOT OVER FILL.
8.1.3. Only use clean high quality lubricating oil. Do not use old or dirty oil as this will
a ect the performance and longevity of the generator. This generator is tted with an
OIL ALERT SENSOR and will NOT start if there is insu cient oil in the sump/engine.
X
8.2. CLEANING AIR FILTER:
X
CAUTION:
Do not wash the elements with kerosene, gasoline or oil.
A dirty air lter element will make the starting of the
generator di cult. It will also cause the generator to
under-perform and may cause permanent damage. .
Always keep the air lter element clean.
8.2.1. The urethane foam element must be washed with a cleaning detergent. After
cleaning it ensure that it is dried properly before reinstalling.
Please clean every 100 hours
8.2.2. Clean the paper element by tapping and blowing it gently to remove dirt and
dust. Never use oil to clean the paper element. Please clean every 50 hours and
replace every 200 hours.
Please clean the air lter elements more often when operating in dusty
environment.
OIL DRAIN PLUG
51