Schneider Airsystems A 888 007 Manual De Instrucciones Original página 45

Problem
L Unusual running
noises.
M The tank for the
water separator
with filter is full of
condensate
2.9 Flow diagram
01 Electric motor
02 Compressor unit
03 Check valve
04 Safety valve
05 Dirt arrester
06 Vessel
07 Pressure gauge (vessel pressure)
08 Pressure reducer
09 Pressure gauge (working pressure)
10 Compressed air connection (cleaned
compressed air)
11 Water separator with filter
12 Compressed
pressed air with oil vapour)
13 Mist oiler
14 Condensate evaporator
15 Throttle (adjustable)
16 3/2-way valve
17 Throttle
18 Pressure switch
(Figure 16a)
Cause
V-belt sags.
Mechanical defect on the com-
pressor unit
Mechanical defect in the motor
Attached parts loose
Fan wheel rubs against the
mounting or is loose
The float divertor filter element
is dirty.
air connection (com-
Remedy
X Tighten
Chap. 2.6.9)
X Notify Schneider Druckluft Ser-
vice
X
Notify Schneider Druckluft Ser-
vice
X
Tighten attached parts.
X
Check the mounting or seat of
the fan wheel or tighten fan
wheel.
X
Clean
Chapter 2.6.8)
2.10 Spare parts service
Visit our website
tems.com/td/ for the latest version of all ex-
ploded drawings and spare parts lists for our
products. If you have any special questions,
please consult the Schneider Airsystems Ser-
vice centre in your country (addresses in the
service appendix) or your local dealer.
2.11 Warranty conditions
Basis for warranty claims: complete unit
in original condition/proof of purchase.
According to legal provisions, you re-
ceive the following warranty against
material and manufacturing defects:
private use only: 2 years,
commercial use: 1 year.
Excluded warranty claims: Wear/consum-
able parts; improper use; overload; manipu-
lation/use for other than intended use;
insufficient/incorrect/no maintenance; accu-
mulation of dust/dirt; incorrect/impermissi-
ble work methods; failure to observe the
Instruction Manual; incorrect processing/
working materials; incorrect electrical con-
nection; improper installation.
MAS Silent
the V-belt
filter element
www.schneider-airsys-
GB
(see
(see
II/21