Briggs & Stratton Power Built 210000 Manual De Operador página 6

AIR CLEANER Fig. 6
CAUTION:
Do not use pressurized air or solvents to
clean cartridge. Pressurized air can damage cartridge;
solvents will dissolve cartridge.
Extended Life Series
Air Filter Cartridge
This filter, IF STAMPED 'WASHABLE', can be washed with
warm water and mild soap.
IMPORTANT: Rinse in tap water with SCREEN side up
allowing dirt and debris to filter out.
Leave filter to dry overnight before reinstalling.
Cartridge removal / installation
Ê
1. Pull up on air cleaner cover
Ë
towards engine.
ÌÏ.
2. Remove cover
3. Carefully lift air cleaner cartridge
Î
, if equipped, from blower housing.
4. Clean air cleaner base carefully to prevent debris from
.
falling into carburetor
5. Place new pre-cleaner, if equipped, and cartridge firmly
in base.
Ð
6. Align tabs on cover with slots
and replace cover.
7. Hook handle and close cover.
HIGH FLOW AIR CLEANER −
CYLINDER FILTER
Ê
This filter is made of cotton, which is different from a
standard paper filter, it MUST be oiled.
1. Spray the filter with air filter cleaning solution. Allow filter
to soak in solution for 15 minutes.
CAUTION:
Never use detergents, high pres-
sure water, or gasoline to clean this filter.
2. Rinse the filter with warm water. Let the water run from
clean side to the dirty side.
3. Allow filter to dry completely. It is best to allow the filter to
dry naturally. Do not use heat, this may shrink the cotton.
4. USE ONLY AIR FILTER OIL, such as the oil included in
the cleaning kit (P/N 5089D), to re-oil the filter.
WARNING
Never use motor oil, transmission fluid, WD40, or
other oils. Failure to follow instructions can cause
fires resulting in death or serious injury. Use only
air filter oil designed specifically for air filters.
5. Pour or spray a small amount on each pleat. Allow the oil
to soak into the filter for 20 minutes. The filter is correctly
oiled when the cotton changes to the color of the oil.
CAUTION:
DO NOT over-oil air filter, it will
interfere with engine performance and may cause
engine damage. If the filter is placed on cardboard
for 10 minutes and leaves a stain, it is over oiled.
Wash/clean and re-oil per above instructions.
6. Re-install air filter.
SPARK PLUG
Ê
Ë
Check the spark plug every season. Replace the spark plug if
upon inspection the electrodes are burned or worn. Ensure the
spark plug is clean. Check the gap with a feeler gage
reset to .76 mm or 0.030 in.
CLEANING DEBRIS
Daily or before every use, clean accumulated debris from
E
Ê
engine. Keep linkage, springs and controls clean.
¾
area around and behind the muffler free of any combustible
Ì
debris.
CAUTION: Do not use water to clean engine parts. Water
could contaminate fuel system. Use a brush or dry cloth.
WARNING
handle, and rotate
Engine parts should be kept clean to reduce the risk of
overheating and ignition of accumulated debris.
Í
, and pre-cleaner
MUFFLER
WARNING
Replacement parts for the muffler must be the same and
Ñ
of blower housing
installed in the same position as the original parts, otherwise
fire can occur.
If muffler is equipped with spark arrester screen, remove
screen for inspection. Replace screen if damaged or plugged
with debris.
Fig. 7
FUEL SYSTEM / IN-LINE FUEL FILTER
WARNING
Replacement parts for fuel system (caps, hoses, tanks, filters,
etc.) must be the same as the original parts otherwise fire can
occur.
Fuel Filter − Drain fuel tank or close fuel shut-off valve before
replacing fuel filter, otherwise fuel can leak out, creating a
potential hazard.
AIR COOLING SYSTEM
It is recommended to clean the air cooling system with blower
housing removed every 100 hours. Clean areas shown.
STORAGE
Engines stored over 30 days need to be protected or drained of
fuel to prevent gum from forming in fuel system or on essential
carburetor parts.
For engine protection, we recommend use of Briggs & Stratton
Fuel Stabilizer available from an Authorized Briggs & Stratton
Service Dealer. Mix stabilizer with fuel in fuel tank or storage
container. Run engine for a short time to circulate stabilizer
through carburetor. Engine and fuel can be stored up to 24
months.
Note: If stabilizer is not used or if engine is operating on
gasoline containing alcohol, e.g. gasohol, remove all fuel from
tank and run engine until it stops from lack of fuel.
1. Change oil.
2. Remove spark plug and pour about 30 ml (1 oz) of
engine oil into cylinder. Replace spark plug and crank
slowly to distribute oil.
3. Clean grass and chaff from cylinder and cylinder head
fins, under finger guard and behind muffler.
4. Store in a clean and dry area, but NOT near a stove,
furnace or water heater which uses a pilot light or any
device that can create a spark.
SERVICE
See an Authorized Briggs & Stratton Service Dealer. Each one
carries a stock of Genuine Briggs & Stratton Parts and is
equipped with special service tools. Trained mechanics
assure expert repair service on all Briggs & Stratton engines.
Only dealers advertising as Authorized Briggs & Stratton" are
required to meet Briggs & Stratton standards.
Ê
When you purchase equipment powered by a
and
Ë
Briggs & Stratton engine, you are assured of
if necessary.
highly skilled, reliable service at more than
Fig. 8
30,000 Authorized Service Dealers world-
wide, including more than 6,000 Master
Service Technicians. Look for these signs
Ë
wherever Briggs & Stratton service is offered.
Keep
You may locate your nearest Authorized Briggs & Stratton
Service Dealer in our dealer locator map on our web site
www.briggsandstratton.com
Note: Walking fingers logo and Yellow Pages" are registered
trademarks in various jurisdictions.
An illustrated shop manual includes Theories of Operation,"
common specifications and detailed information covering
adjustment, tune-up and repair of Briggs & Stratton single
cylinder, OHV, 4 cycle engines. Order the shop manual from an
Authorized Briggs & Stratton Service Dealer. Order P/N
272147 for all models.
Insist on Genuine Briggs & Stratton replacement parts with our
logo on the box and/or part. Non-original parts may not perform
as well and may void your warranty.
Models 280000, 310000 AVSE Series
Extended Life SeriesE flat air cleaner cartridge
(washable, no pre-cleaner required)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Extended Life SeriesE Maintenance Kit
(Includes oil, A/C filter, spark plug, gas additive)
Flat air cleaner cartridge and pre-cleaner kit
Flat air cleaner cartridge
Flat air cleaner pre-cleaner
Maintenance Kit
(Includes oil, A/C filter, spark plug, gas additive)
UL approved Flat air cleaner cartridge
(For NG/LPG Gaseous Fuel engines only.)
Model 210000 AVSE Series
Fig. 9
Flat air cleaner cartridge and pre-cleaner kit
Flat air cleaner cartridge
Flat air cleaner pre-cleaner
Ê
Maintenance Kit
(Includes oil, A/C filter, spark plug, gas additive)
Oval air cleaner cartridge and pre-cleaner kit
Oval air cleaner cartridge
Oval air cleaner pre-cleaner
High Flow Air Filter (cylinder)
High Flow Air Filter Cleaning Kit
Synthetic Oil (32 oz.)
Oil (20 oz.)
Oil (48 oz.)
Oil filter (6 cm long)
Oil filter (8.5 cm long)
Fuel stabilizer (30 ml, single use pouch)
Fuel stabilizer (125 ml)
Fuel filter (without fuel pump)
Extended Life Series Fuel filter
(for engines with fuel pump)
Fuel filter (for engines with fuel pump)
Resistor spark plug
Long life platinum spark plug
(used on most OHV engines)
Spark tester
Spark plug wrench
Oil pump kit (uses standard electric drill to
remove oil from engine quickly)
4
or in the
Pages™" directory under Engines, Gasoline"
or Gasoline Engines," or Lawn Mowers" or
™
similar category.
PARTIAL LIST OF GENUINE
BRIGGS & STRATTON PARTS
. . . . . . . .
. . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . 492932 -or- 5049
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . .
. . . . . . . . . . . . 999005E -or- 5041
. . . . . . . . . 298090 -or- 5018
. . . . . . . . . . 695666 -or- 5070
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . 89838 -or- 5023
. . . . . . . . . . . . . . . .
Yellow
697153
5128
5077
698083
697015
5127
790263
5079
698413
697292
5126
5053
496894
272403
698973
5089D
100074
100005
100028
491056
992030
394358
491055
5066
19368
5056