California Proposition - Troy-Bilt TB2BV EC Manual De Uso

TABLE OF CONTENTS
Service Information ................................................................ 2
Safety Information ................................................................ 2
Assembly Instructions ............................................................. 3
Oii and Fuel Information ............................................................ 3
Starting and Stopping Instructions .................................................... 3
Operahng Instructions ............................................................. 3
Maintenance and Repair Instructions .................................................. 4
Cleaning and Storage .............................................................. 4
Optional Accessory ............................................................... 4
Troubleshooting .................................................................. 4
Specifications .................................................................... 4
Warranty Information ............................................................. 16
All mformahon, illustrations, and specifications ,q this manual are based on the latest product information
available at the time of pnnhng. We reserve the right to make changes at any time without notice.
Copyright© 2011 MTD SOUTHWEST INC, All Rights Reserved.
DO NOT RETURN THiS UNIT TO THE RETAILER. PROOF OF PURCHASE WILL BE REQUIRED
FOR WARRANTY SERVICE.
For ass=stance regarding the assembly, controls, operation or maintenance of the un=t, please call the
Customer Support Department at 1=800=828=5500 in the United States or 1=800-668=1238 m Canada.
Addlhonal mformahon about the umt can be found on our webslte at www.troybilt.com or
www.troybilt.ca.
For serwce, please call the Customer Support Department to obtaHq a list of authorized service dealers
near you. Service on this umt, both within and after the warranty period, should only be performed by an
authonzed and approved service dealer. When servicing, use only idenhcal replacement parts.
SPARK ARRESTOR NOTE
NOTE: For users on U.S. Forest Land and in the states of California, Maine, Oregon and Washington.
All U.S. Forest Land and the state of Cahfornla (Pubhc Resources Codes 4442 and 4443), Oregon and
Washington require, by law that certain ,_ternal combustion engines operated on forest brush and/or grass-
covered areas be equipped with a spark arrestor, ma,qta,qed ,q effective work,qg order, or the engine be
constructed, equipped and maintained for the prevention of fire. Check with your state or local authonhes for
regulations perta,qlng to these requirements. Failure to follow these requirements could subject you to hablhty
or a fine. This unit is factory equipped with a spark arrestor. If it requires replacement, ask your LOCAL
SERVICE DEALER to install the Accessory Part #753=06027 Muffler Assembly.
• SAFETY ALERT SYMBOLS •
Safety alert symbols are used to draw your attention to possible dangers. These symbols, and their
explanahons, deserve your careful attenhon and understanding. The safety warnings do not by
themselves eliminate any danger. The instructions or warnings they give are not substitutes for
proper accident prevent=on measures. These safety mstruchons are not meant to cover every
possible condition that may occur. If queshons arise, please call the Customer Support
Department at 1=800=828=5500 (U.S.) or 1=800=668=1238 (Canada).
SYMBOL MEANING
DANGER:
S@qals an EXTREME hazard.
Failure to obey a safety DANGER signal WiLL result in serious injury or death to yourself or
to others.
__ I WARNING:
Signals a SERIOUS hazard.
Failure to obey a safety WARNING s@qal CAN result in senous injury to yourself or to others.
[_.l CAUTION:
Signals a MODERATE hazard.
Failure to obey a safety CAUTION signal MAY result in property damage or injury to
yourself or to others.
IMPORTANT! Signals special mechanical informahon.
NOTE: S@qals addlhonal important general mformahon.
,, To reduce the risk of hearing loss associated with sound level(s), always wear ear/heanng
protection when operating this unit.
,, Wear heavy long pants, boots, gloves, and a long sleeve shirt. Do not wear loose clothing, jewelery,
short pants, sandals or go barefoot. Secure hair above shoulder level.
,, Wear a face or dust mask if the operahon is dusty.
,, To avoid static electricity shock, do not wear rubber gloves or any other insulated gloves while
operating th_s umt.
,, Use the unit only m dayhght or good artificial hght.
,, Keep all surfaces free from oll and fuel.
,, Avoid accidental starting. Be m the starting position whenever pulhng the starter rope. The operator
and unit must be in a stable poslhon while starting. Refer to Starting and Stopping Instructions.
,, Do not set unit on any surface except a clean, hard area while engine is running. Debris such as
gravel, sand, dust, grass, etc. could be picked up by the air retake and thrown out by the discharge
opening, damaging unit, property, or causing serious injury to bystanders or operator.
,, Only use the unit for its intended purpose. Only use the unit as described in this manual.
,, Do not force the umt. It will do the job better and with less hkehhood of injury at a rate for which it
was designed.
,, Do not overreach or use from unstable surfaces such as ladders, trees, steep slopes, rooftops, etc.
Always keep proper footing and balance.
,, Always hold the umt with a firm grip when operating.
,, Keep hands, face, and feet away from all moving parts. Do not touch or try to stop the impeller
when it is rotating. Do not operate without guards m place.
,, Do not put any object into openings. Do not use with any opening blocked; keep free of dirt, debris,
and anything that may reduce the air flow.
,, Do not touch the engine or muffler. These parts get extremely hot from operahon, even after the
unit Is turned off.
,, Do not operate the engine faster than the speed needed to do the job. Do not run the engine at
high speed when not m use.
,, Always stop the engine when operahon is delayed or when walk,_g from one Iocahon to another.
,, Stop the engine for maintenance, repair, to install or remove the blower tubes or vacuum
attachments. The Emit must be stopped and the impeller no longer turning to avoid contact with the
rotating blades.
,, If you strike or come into contact with a foreign object, stop the engine immediately and check for
damage. Do not operate before repalnng damage. Do not operate the unit with loose or damaged parts.
,, Use only original equipment manufacturer replacement parts and accessories for this unit. These
are available from an authorized serwce dealer. The use of any unauthorized parts or accessories
could lead to serious injury to the user, or damage to the unit, and void the warranty.
,, Never use this unit for spreading chemicals, ferhhzers or other substances which may contain toxic
materials.
,, To reduce fire hazard, replace faulty muffler and spark arrestor. Keep the engine and muffler free
from grass, leaves, excesswe grease or carbon build up.
,, Never point the blower in the dlrechon of bystanders, animals, windows or automobiles.
,, Avoid situations that could catch the vacuum bag on fire. Do not operate near an open flame. Do
not vacuum warm ash from fire-places, barbecue p_ts, brush plies, etc. Do not vacuum d_scarded
cigars or cigarettes unless the cinders are completely cool.
,, The unit is designed to pickup dry material such as leaves, grass, small twigs, and bits of paper. Do
not attempt to vacuum wet debris and/or standing water as th_s may result m damage to the
blower/vacuum. To avoid severe damage to the impeller, do not vacuum metal, broken glass, etc.
OTHER SAFETY WARNINGS
,, Always disconnect the spark plug before performing maintenance or accessing movable parts.
,, Never store the unit. with fuel in the tank, inside a building where fumes may reach an open flame
(pilot hghts, etc.) or sparks (switches. electrical motors, etc.).
', Allow the engine to cool before storing or transporting. Be sure to secure the unit while transporting.
,, Store the unit m a dry place, either locked up or up high to prevent Lmauthonzed use or damage.
Keep out of the reach of children.
,, Never douse or squirt the unit with water or any other hquld. Keep handles dry, clean, and free from
debris. Clean after each use, see Cleaning and Storage instruchons.
,, Keep these mstruchons. Refer to them often and use them to instruct other users. If you loan this
umt to others, also loan these mstruchons to them.
SPECIAL NOTE: Exposure to vibrations through prolonged use of gasohne powered hand tools could
cause blood vessel or nerve damage m the fingers, hands, and joints of people prone to circulation
disorders or abnormal swelhng. Prolonged use in cold weather has been hnked to blood vessel
damage m otherwise healthy people. If symptoms occur such as numbness, pare, loss of strength,
change m skin color or texture, or loss of feehng m the fingers, hands or joints, dlsconhnue use of this
too! and seek medical attention. An anh-wbrahon system does not guarantee avoidance of these
problems. Users who operate power tools on a regular basis must closely monitor their physical
cond_hon and the cond_hon of th_s tool.
SAVE THESE iNSTRUCTiONS
Read the Operator's Manual and follow all warnings and safety instructions. Failure to do so
can result in serious injury to the operator and/or bystanders.
FOR QUESTIONS, CALL 1=800=828=5500 IN THE U.S. OR 1=800=668=1238 IN CANADA
,, IMPORTANT SAFETY INSTRUCTIONS ,,
_ CALIFORNIA PROPOSITION 65
WARNING: Engine exhaust, some of its constituents and certain finished components
contain or emit chemicals known to the State of California to cause cancer and b_rth
defects or other reproductive harm. Wash hands after handhng.
READ ALL INSTRUCTIONS BEFORE OPERATING
I _ I WARNING:
When us,qg the unit. you must follow the safety rules. Please read these
_nstruct_ons before operating the unit in order to ensure the safety of the operator and any
bystanders. Please keep these mstruchons for later use.
,, Read the instruchons carefully. Be familiar w_th the controls and proper use of the unit.
,, Do not operate this unit when bred, iii, or under the influence of alcohol, drugs, or medlcahon.
,, Children and teens under the age of 15 must not use the unit, except for teens guided by an adult.
,, All guards and safety attachments must be installed properly before operahng the unit.
,, Inspect the unit before use. Replace damaged parts. Check for fuel leaks. Make sure all fasteners
are m place and secure. Replace parts that are cracked, ch_pped, or damaged _nany way. Do not
operate the umt w_th loose or damaged parts.
,, Carefully respect the area before starting the unit. Remove all debris and hard or sharp objects such
as glass, w_re. etc.
,, Clear the area of children, bystanders, and pets. At a minimum, keep all children, bystanders, and pets
outside a 50 feet (15 m) radius; there still may be a risk to bystanders from thrown objects. Bystanders
should be encouraged to wear eye protection. If you are approached, stop the unit immediately.
SAFETY WARNINGS FOR GAS UNITS
-- i
L_ ARNING:
Gasohne is highly flammable, and its vapors can explode if @qlted. Take the
following precautions:
,, Store fuel only m containers specifically des@_ed and approved for the storage of such materials.
,, Always stop the engine and allow it to cool before fllhng the fuel tank. Never remove the fuel tank
cap or add fuel when the engine _shot. Always loosen the fuel tank cap slowly to reheve any
pressure _nthe tank before fuehng. Do not smoke.
,, Always mix and add fuel in a clean, well-ventilated outdoor area where there are no sparks or
flames. Do not smoke.
,, Never operate the unit without the fuel cap securely in place.
,, Avoid creating a source of @_lhon for spilled fuel. Wipe up any spilled fuel from the unit
_mmed_ately before starting the Emit. Move the unit at least 30 feet (9.1 m) from the fuehng source
and s_te before start,qg the eng,qe. Do not smoke.
,, Never start or run the unit inside a closed room or building. Breathing exhaust fumes can kill.
Operate th_s umt only _na well-ventilated outdoor area.
WHILE OPERATING
,, Wear safety glasses or goggles that are marked as meehng ANSI Z87.1-1989 standards.
,, Never run the unit w_thout the proper equipment attached. Do not operate the umt w_thout the
blower tubes or vacuum tubes and vacuum bag attached. Make sure the vacuum bag _scompletely
z_pped closed.
SAFETY AND INTERNATIONAL SYMBOLS "
Th_soperator's manual descnbes safety and ,_ternat_onal s ymbols and p_ctographs that may appear on thB product
Read the operator's manual for complete safety assembly, operat,_g, ma=ntenance and repa=r=nformat=on
SYMBOL
Ax
©
|
O
H IqH )
MEANING
SAFETY ALERT SYMBOL
Ind_cates danger, warning or caution. May be used m conjunction w_th other symbols
or p_ctographs.
READ OPERATOR'S MANUAL
WARNING:
Read the operator's manual(s) and foHHow air warnings and safety
,nstruct,ons. Failure to do so can resuHtm senous injury to the operator and/or bystanders.
• WEAR EYE AND HEARING PROTECTION
WARNING:
Thrown objects and Houdno_se can cause severe eye injury and heanng
Ross.Wear eye protection meeting ANSI Z87.1-1989 standards and ear protechon when
operating thB un,t. Use a fuHH face sh,eld when needed.
UNLEADED FUEL
Always use clean, fresh unleaded fueH
OIL
Refer to operator's manual for the proper type of oil.
DO NOT USE E85 FUEL iN THiS UNHT
WARNING: It has been proven that fuel containing greater than 10% ethanol w_ll
I_keiydamage th_s engine and void the warranty.
= ON/OFF STOP CONTROL
ON / START / RUN
• ON/OFF STOP CONTROL
OFF or STOP
PRIMER BULB
Push pnmer bulb, fully and slowly, I0 times.
CHOKE CONTROL
1. _ FULL choke posit,on
2. • PARTIAL choke pos,t,on
3. * RUN choke poslhon
THROWN OBJECTS CAN CAUSE SEVERE INJURY
WARNING:
Small objects can be propelled at h,gh speed, causing injury.