Fuel Supply - Koshin SEV-25L Manual De Instrucciones

PARTS LIST
EN
SEV-25L
No. PARTS CODE PARTS NAME
1 0113329 PUMP CASE
2 0113325 SUCTION FLANGE
3 0113326 CHECK VALVE
4 0148010 15A PLUG SET
5 0118450 32A PLUG SET
6 0114992 FLANGE BRACKET
7 0112528 VOLUTE CASING
8 0114993 IMPELLER
9 0140251 ADJUSTING WASHER (0.3)
10 0121628 ADJUSTING WASHER (0.6)
11 0116054 MECHANICAL SEAL
12 890255031 O-RING (1517-31)
13 889855042 O-RING (P42)
14 743119032 BOLT (M6X20)
15 743119045 BOLT (M8X20)
16 743119046 BOLT (M8X22)
17 743119043 BOLT (M8X16)
18 734532274 SOCKET BOLT (M5X40)
19 854255005 SEAL WASHER (φ5)
QTY No. PARTS CODE PARTS NAME
1 20 0348124 COUPLING SET
1 21 0121745 COUPLING
1 22 0121659 NIPPLE
1 23 0340065 COUPLING PACKING
1 24 0118193 STRAINER
1 25 940019032 HOSE BAND (φ32)
1 26 0118267 BASE SET
1 27 0112576 PIPE RUBBER
1 28 - ENGINE (KC26-B0)
1 29 0114277 HANDLE
1 30 0121740 NAME PLATE
1
1
3
2
2
2
4
4
- 2 -
CAUTION
1.Application
1.Application
As this pump is exclusively used for agriculture,
do not apply muddy water.
*Trouble if you don't observe.
Damage of mechanical seal
2. Priming
As this pump is of self-priming type, pour water
fully from priming port before running.
*Trouble if you don't observe.
Impossible pumping
Damage of mechanical seal

3. Fuel supply

Fill the fuel tank with the fuel. Be sure to stop the engine before supplying the
fuel. Fuel to be used; Mixture of oil and gasoline mixed at the ratio of 50
(lead-free gasoline):1(oil).
When the quality of mixed oil is low, the ignition plug is contaminated excessively
and an increased amount of carbon accumulates in the muffler and cylinder.
Be sure to use the oil specially made for 2 cycles and sold by each petroleum
maker in the commercial market.
4. Connection of suction hose
QTY
If priming is not made by running after pouring water from priming port, it is
2
almost because of imperfect connection of suction hose. In such sa case, run
2
after checking again connectin of hose.
2
*Trouble if you don't observe.
2
1 Impossible pumping
3
1
5. Drain of water after use
4
Water inside casing freezes at below 0℃ in winter and thereby pump may
1
possibly be broken. After use, drain water from drain port at bottom to store.
1
*Trouble if you don't observe.
1
Breakage of pump casing
1
PRIMING
PLUG
DRAIN PLUG
- 3 -
EN