Maintenance - DOSMATIC TurboDos 100 Manual De Operación

Clean Solution Container
Keep covered to prevent dirt and flying debris from
entering the container. Rinse container thoroughly and
often. Do not mix chemicals together that might react
and cause a precipitate. Use FILTERED diesel when
filling container.
Clean Suction Tube Filter Screen
Inspect each time new solution is added. Clean filter
screen (#27) and suction tube (#25) as necessary by
rinsing in fresh water. Replace if necessary. Keep filter
screen off bottom of solution container to prevent dirt
and precipitate from clogging filter.
Clean Inlet Filter
Clean or replace inlet filter as required to increase the
life of the unit as well as reduce pressure loss.
Bypass Injector
When not in use place the injector in bypass mode by
using the three valve bypass.
Storage
For extended storage, rinse injector (see "Rinse Injector
After Each Use") and place underwater in a container.
Apply monthly, <0.1 oz. (29 ml) of chlorine bleach to
avoid algae growth. KEEP FROM FREEZING.
English: 12

Maintenance

Reference numbers refer to Page 15 - 22
Every 3 - 6 Months
1. Clean seal areas (#14
or #51 - 0.25%).
2. Check (#37) Cylinder,
clean and/or replace as
necessary.
1. Clean seal areas (#14
or #51 - 0.13%).
2. Check (#37) cylinder,
clean and/or replace as
necessary.
Perform these maintenance
procedures to extend the life of your unit.
Refer to page 16 - 18
TurboDos 100 (0.5%, 1% & 0.25%) Models
Every 6 - 12
months
1. Replace (#14) O-ring
and (#44) Dosage Piston.
2. Clean and/or replace
(#13) Check Poppet,
(#11) Suction Tube
Fitting.
Refer to page 20 - 22
TurboDos 200/400 (0.25%, 0.5% & 0.13%) Models
Every 3 - 6 Every 6 - 12
Months months
1. Replace (#14) O-ring
and (#44 or #51 -
0.13%) Dosage Piston.
Clean and/or replace.
2. (#13) Check Poppet,
(#11) Suction Tube
Fitting.
Replace as
necessary
1. (#37) Cylinder
2. (#14) O-ring
3. (#44) Dosage Piston
or #51 Lower Shaft
Assy - 0.25%.
Replace as
necessary
1. (#37) Cylinder
2. (#14) O-ring
3. (#44) or (#51)
Shaft Assembly
Dosage Piston