Troubleshooting - Truper GEN-100X Manual Del Usario

Troubleshooting

Problem Cause
The engine does not • The fuel stopcock is off.
start. • Not enough fuel.
• Loads connected to the a.c. contacts.
• There is no spark in the spark plug.
• Gasoline is not reaching the carburetor.
• Oil level is too low.
• Thermal protection has not been reset.
Motor starts but it • Oil level is too low.
stops suddenly.
The generator is not • Thermal protector has not been reset.
showing voltage in the
output. • Some of the power devices are not working
(For example, a lamp is not working).
If the problems persist despite carrying out the recommended corrective actions,
contact a
Solution
• Turn on the fuel stopcock.
• Fill up fuel tank.
• Disconnect any load from the generator.
• Verify the spark plug spark:
1. Disconnect the spark plug cable. Clean dust
around spark plug and remove it.
2. Connect the cable to the spark plug.
3. Turn on the engine switch.
4. Make contact with the spark plug central
electrode with any fuel - free metal part in the
CAUTION
motor.
tests in ventilated areas and with no spilled fuel.
Otherwise an explosion can happen.
5. Insert the key into the switch and pull a few
seconds until the "START" position to generate a
spark between the spark plug central electrode
and the metal part. If there is no spark replace
the spark plug.
6. If there is no spark with a new spark plug go to
a
WARNING
been spilled before starting the engine, check
that the area around the spark plug and the
generator is dry. The spill of fuel or excess of
steam could cause an explosion.
• Check oil level and add if necessary.
• If the engine cannot be started go to a
to repair.
• Check oil level and add if necessary.
• Go to a
Center to repair.
• Check the status of the devices before
connecting them and repair any damaged device
before using it with the generator .
• Check that the thermal overload protector is in
the "ON" position.
Authorized Service Center
Is important to make the
Authorized Service Center.
• Make sure that no fuel has
Authorized Service Center
Authorized Service
ENGLISH
15