Important Safety Instructions; General Specifications - BriskHeat IBC Manual De Instrucciones

IMPORTANT SAFETY INSTRUCTIONS

DANGER
A person who has not read
and understood all
operating Instructions is
not qualified to operate
this product.
DANGER

Do not immerse or spray any
component of the control system with
liquid.

Keep volatile or combustible material
away from controller when in use.

Do not use heater in hazardous
locations.

Keep sharp metal objects away from
heater.
Failure to observe these warnings may
result in electric shock, risk of fire, and
personal injury.
WARNING
End-User Must Comply to the Following:

Only qualified personnel are allowed to connect the electrical wiring.

All electrical wiring must follow local electrical codes.

The person who performs the final installation / wiring must be qualified for this work.

The end-user is responsible for providing a suitable disconnecting device.

The end-user is responsible for providing suitable over-protection device. It is highly
recommended that a ground fault circuit breaker be used.
Failure to observe these warnings may result in personal injury or damage to the heater.
®
© BriskHeat Corporation. All rights reserved.
Wrap-Around Tote Tank /IBC Heater
(TOTE & TOT Series)
CAUTION

Inspect heater before use. Do not
use heater with torn or worn surfaces.

Do not repair damaged or faulty
heater.

Do not crush or apply severe physical
stress on heater or cord assembly.

Unplug heater when not in use.

Use heater for heating tote tanks /
IBCs only. Use specific sized heater
with same sized tote tank / IBC. Do
not use for other applications.
Failure to observe these warnings may
result in personal injury or damage to the
heater.
3

GENERAL SPECIFICATIONS


Full coverage plug and play system

Two separate heat zones

Silicone impregnated cloth inner and outer layer

1/4" (6mm) fiberglass insulation

Patented grounded heating element for your safety

Voltage: See identification label

Total wattage: See identification label

Adjustable thermostat: 50-160°F (10-71°C). Some models equipped with a thermostat
controlled at a specific temperature. See identification label.

Built-in manual reset high-limit safety thermostat set at 195°F (91°C) for each heat
zone

Power cord 6 feet (1.8M) long with standard plug:
120VAC = NEMA 5-15
230VAC = Crimped Ferrule Wire Connection
Other voltages = bare wire

Optional insulated top cover [reduces heat loss]
TOTE Series: Units with Adjustable Straps and Buckles

Fits any tote tank width from 40" x 40" (1016mm x 1016mm) to 48" x 48"
(1219mm x 1219mm)
Top Support straps and Buckles
Adjustable
Thermostat
Control Knobs
(if applicable)
"Mouse-hole"
for spigot
®
© BriskHeat Corporation. All rights reserved.
Wrap-Around Tote Tank /IBC Heater
(TOTE & TOT Series)
Manual Reset
High–Limit
Thermostat
Adjustable
Straps and
Buckles
6 ft (1.8m)
Power Cord with Plug
4