SATA AE5302 Manual Del Uso página 44

2.3.9 Lift the sub-lift （to a height not greater than the main lift）, and then lower it. It is recommended to repeat this step 3 times.
Main lift
The height of the sub-lift shall not be greater than that of the main lift
2.3.10 Taking the main lift as the benchmark, lift the sub-lift to place the main lift and sub-lift at the same level, and turn the red
handle to close the high-pressure valve. When the Main Lift and Sub Lift are adjusted properly, set the Work/Adjust switch to
Work, and set the time relay to 1.5~2s.
Main lift
2.4 Emergency manual lowering in case of power failure:
Lift the safety gears above the cylinders of the two platforms and hold them with paper pads to ensure the safety gears are
completely detached from the gear racks, switch off the power supply, open the door of the control cabinet and select the
corresponding solenoid valve, loosen the copper nut at the rear of the oil return solenoid valve （9）, and then push the front ends
of the two solenoid valves （the left one to control the Main Lift, and the right one to control the Sub Lift） with a small hex key
to perform manual lowering. After lowering, screw the copper cap at the rear of the oil return solenoid valve quickly. Otherwise,
when the power is switched on and the lift is rising, the hydraulic oil will flow back to the hydraulic tank directly and cannot push the
cylinder to raise the lift, which will cause unnecessary trouble. Do not perform this operation except in case of an emergency.
2.5 Schematic diagram of main components:
Turntable recess
Side slide plate
Stop plate
Sub Lift
Safety tooth
Control cabinet
44
AE5302/AE5302-3
Sub-lift
Sub-lift Close
accommodate the turntable for four-wheel alignment
accommodate the turntable for four-wheel alignment
prevent the vehicle from sliding out of the platform. This plate is laid flat when the lift is at the lowest position
The height shall not be
greater than that of the
main lift
Red handle After oil filling
of Main Lift
and Sub Lift
lift the vehicle further
safety mechanism, for mechanical locking
control unit, providing the power takeoff.
中文
EN DE RU KO
Work Adjust
PT JA ES