Publicidad
Idiomas disponibles
Idiomas disponibles
OPERATION AND SERVICE INFORMATION
Read all of Manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
installed are considered 'wet' and require approximately 80% of the torque required for 'dry' fasteners.
BOLT SIZE
1/4"
Grade 2
(5)
Grade 5
(8)
Grade 8
(8)
BOLT SIZE
M4
Class 5.8
(Grade 2)
(2)
5.8
Class 8.8
(3)
(Grade 5)
8.8
Class 10.9
10.9
(4)
(Grade 8)
Ref Tsp 1
Batteries are heavy. Use
proper lifting techniques
when moving them. Always
lift the battery with a com-
mercially available battery
lifting device. Do not tip bat-
t eri es wh en re movin g o r
installing them; spilled elec-
trolyte can cause burns and damage.
The electrolyte in a storage battery is an
acid solution which can cause severe burns
to the skin and eyes. Treat all electrolyte
spills to the body and eyes with extended
flushing with clear water. Contact a physi-
cian immediately.
Always wear a safety shield or
approved safety goggles when
adding water or charging batter-
ies.
Any electrolyte spills should be neutralized
with a solution of 1/4 cup (60 ml) sodium
bicarbonate (baking soda) dissolved in 1 1/2
gallons (6 liters) of water and flushed with
water.
Page 20
ALL TORQUE FIGURES ARE IN FT. LBS. (Nm)
Unless otherwise noted in text, tighten all hardware in accordance with this chart.
This chart specifies 'lubricated' torque figures. Fasteners that are plated or lubricated when
5/16"
3/8"
4
8
15
(11)
(20)
6
13
23
(18)
(31)
6
18
35
(24)
(47)
M5
M6
1
2
4
(3)
(6)
2
4
7
(6)
(10)
3
6
10
(8)
(14)
Fig. 24 Torque Specifications and Bolt Grades
Owner's Manual and Service Guide
7/16"
1/2"
9/16"
24
35
55
(33)
(47)
(75)
35
55
80
(47)
(75)
(108)
55
80
110
(75)
(108)
(149)
M8
M10
M12
10
20
35
(14)
(27)
(47)
18
35
61
(24)
(47)
(83)
25
49
86
(34)
(66)
(117)
Overfilling batteries may result in electrolyte
being expelled from the battery during the
charge cycle. Expelled electrolyte may
cause damage to the vehicle and storage
facility.
Aerosol containers of battery terminal pro-
tectant must be used with extreme care.
Insulate metal container to prevent can from
contacting battery terminals which could
result in an explosion.
'shorting out' a battery, which could result in
an explosion and severe personal injury or
death.
BATTERY
A battery is defined as two dissimilar metals immersed in
an acid. If the acid is absent or if the metals are not dis-
similar, a battery has not been created. The batteries
most commonly used in these vehicles are lead acid.
5/8"
3/4"
7/8"
75
130
125
(102)
(176)
(169)
110
200
320
(149)
(271)
(434)
170
280
460
(230)
(380)
(624)
M14
55
(76.4)
97
(131)
136
(184)
Wrap wrenches with
vinyl tape to prevent
the possibility of a
dropped wrench from
1"
190
(258)
480
(651)
680
(922)
Publicidad
Capítulos
