General Notes; Safety Warnings - TowCar Racing AEPM030 Manual De Instrucciones

GB

General notes

Thanks for purchasing a TowCar product.
The new TowCar Racing is tow ball mounted motorbike carrier designed and manufactured by Enganches y Remolques Aragón S.L.
With TowCar Racing you can transport your motorbike in a very comfortable and secure way.
The coupling to the tow ball can be done in seconds.
The TowCar Racing is equipped with a complete rear lighting plate.

Safety warnings

Please, carefully read and keep this user manual.
Driver is the only responsible for the correct fixing of the device. Check the coupling system is perfectly attached to the tow ball.
These recommendations are not limited and do not exempt you from the basic rules of prudence and common sense. If any
abnormality is found, contact your dealer before any use.
To calculate the maximum weight of the motorbike we can carry, we must subtract the net weight of rack itself (21Kg) from the
maximum nose load noted in the vehicle owner's manual and the tow bar docuemtnation. For example, if the maximum nose load
of your car is 75 kg, and that noted in the tow bar certificate is 80Kg, you should take the minor of both weights: 75Kg.
Then, payload is calculatied by the subtraction 75 - 21 = 54 Kg.
In any case. The máximum weight of the motorbike must not exceed 75 Kg
Check the secure fastening of the fixation straps according to pictogram 11.
To circulate, it is mandatory that the locking system of the coupling is in "closed" position and the key (E) has been extracted from
the lock (see pictogram 3).
Before to start the trip, check the correct working of the rear lights. Licence plate and rear lights must be always visible.
Ensure that once the motorbike is mounted, there is enough gap between the rack and the vehicle to avoid any physical or
material damage caused by exposure to high temperature gases from the exhaust pipe.
Check that any metal part of the device does not come into contact with the bodywork to avoid any damage.
Legal advise
Always respect the regulations in force in the country which will circulate with the motorbike carrier.
Spanish traffic regulations specify that any vehicle not intended exclusively for transportation, load may only protrude
from the floor of the vehicle by the back 15% of the total length of the vehicle. In which case you must indicate the
external edge of the load with a EC Approved V20 signboard.
It is recommended to remove device after use, for reasons of safety for other road users (pedestrians, bikers, motorists ...
Driving recommendations
Please, before and during the trip, check out the correct fixation of the motorbike. Tighten fasteners, screws and brackets.
Please note that the fact of adding a towball mount device affects the behavior of the vehicle (curves, lateral wind, reversing sharp
bend, etc.) The vehicle is longer. This must be taken into account during maneuvers. Please, adapt the vehicle speed, specially
when driving bumpy roads or offroad.
Guarantee
Any modification, conversion or alteration of any component of the product is prohibited. Any breach leads to the immediate
cancellation of approval and warranty.
Enganches y remolques Aragon, S.L. offers a guarantee of their products for a period of two years from the date of
delivery. Limited to the replacement of defective merchandise and in no case will be extended to damages or
consequential damages.
Enganches y Remolques Aragon S.L. it is not liable for damage caused by injudicious use, overloading or damage by external
agents (knocks, accidents, etc.), misuse or failure to follow instructions.
13
160729 Rev. 2 AEPM030