Installation Instructions - Hudora Turnreck Vario Instrucciones De Montaje Y De Uso

INSTRUCTIONS FOR ASSEMBLY AND USE
EN
CONGRATULATIONS ON PURCHASING THIS PRODUCT!
Please read these instructions carefully. The instructions are an integral component
of the product. Therefore, please store them and the packaging carefully in case
questions arise in the future. Please always include these instructions when handing
on the product to a third party. This product must be assembled by an adult. This
product is designed for private/domestic use only. This product is not designed for
commercial/industrial use. The use of the product requires certain capabilities and
skills. Always adjust according to the age of the user and use for the purpose it has
been designed for.
TECHNISCHE SPEZIFIKATIONEN
Item: Vario gymnastic bars |
Vario gymnastic bars Double bar extension
Item number: 64005, 64006
Maximum load: 120 kg (per horizontal bar)
Dimensions (set in concrete): about 180 x 115 x 9 cm | about 180 x 225 x 9 cm
Purpose: Device for playful gymnastic exercises.
Minimum age for use: 3 years
If you have trouble getting the product ready for use or need additional product
information, please visit our website www.hudora.de, where you will find answers
to all of your questions.
INTRODUCTION
Please read this entire manual completely before using the trampoline. As in any
kind of physical activity, there is a risk of injury involved. Read all instructions and
tutorials before usage. Warnings, care & maintenance instructions are provided to
ensure safe and fun usage of this equipment. Please keep this instruction manual!
SAFETY INSTRUCTIONS
• WARNING! Only for domestic use. Suitable for outdoor use only.
• WARNING! To be used under the direct supervision of an adult.
• WARNING! Not suitable for children under 36 months. Small parts. Choking
hazard. Danger of falling.
• WARNING! This product contains small parts which could cause asphyxia if
swallowed. Supervise children during the assembling.
• Ample headroom is absolutely essential. A minimum clearance of 2 m above the
high bars is recommended. Remove all wires, tree branches and other potential
hazards from the clearance zone.
• Lots of room to move is absolutely indispensible. Make sure you set up the high bar
structure away from walls, buildings, electrical power lines, fences and playground
areas. Keep a minimum clearance of 2.5 m each behind and in front of the
gymnastics high bar. The clearance to the sides should be no less than 1 m each!
• Make sure that the surface beneath the high bar is not too hard. We recommend
grass or rubber mats.
• Remove all objects that could interfere with the gymnast's movements and do not
place any objects whatsoever beneath the high bar. Empty your pants pockets
prior to using the high bar. Take off any jewellery or watches before use.
• Never use indoors!
• The improper or incorrect use of the high bar is dangerous and could result in
severe injuries!
• Use this device only if you are physically fit enough to do so. If you have any
misgivings, please consult with your doctor prior to using it.
• The owner of the gymnastics high bar and the supervising adults present are responsible
for the compliance of all users with the instructions in the operating manual.
• Use the gymnastics high bar only in the presence of experienced supervisors
who have pertinent know-how.
• This product has been designed for a certain maximum weight and a specific use.
Maximum user weight has been mentioned in the Technical Specifications.
• Do not jump onto the high bar from other athletic structures or objects or vice
versa. Do not use the device if you are fatigued. Users should always choose a bar
level that they can reach on their own without the assistance of another person.
Do not use the device when set to heights that are too high for you!
• To prevent slip and fall accidents, make sure that the high bar and the ground are
dry while you are using the structure.
• While the device is in use, all individuals with the exception of a trained supervising
adult should stay clear of the high bar and maintain a distance of 2 m.
• Never allow multiple gymnasts to be on the high bar at the same time!
• The simultaneous use by multiple users increases the risk of injuries such as
head injuries, broken neck, broken legs or spinal cord injuries.
• If a gymnast should fall on the head or nape of the neck, this may result in
paralysis or death!
All images are examples of the design.
• Do not perform somersaults or back flips. These exercises do increase the risk of
falling on your head or nape of the neck!
• Always wear suitable clothing.
• As in any kind of physical activity, there is a risk of injury involved.
• When permanently irradiated with UV light, the material ages significantly faster. To
avoid premature ageing and thereby extend the service life, you should always store
the removable mechanism(s) of the item in a dry and dark place when not in use. Do
not permanently expose the removable mechanism(s) to wind, moisture, extreme
temperatures or sunlight. You should cover the permanently installed parts of the
product with a sheet when not in use, particularly in winter, to protect them from
weather conditions.
• Self-locking nuts are only to be used for one-time assembly.
If you should determine that any of the listed risks or conditions exist that you
consider potential hazards for the user, the high bar must be disassembled or
secured against use until these circumstances have been eliminated.

INSTALLATION INSTRUCTIONS

PRIOR TO THE ASSEMBLY
First and foremost, make sure that you have all of the parts listed below in your
possession. If you should determine that any part is missing, please contact our
service department. Please use gloves to protect your hands against pinching
injuries while you are putting the device together. We recommend that at least
two people should work together when setting up this product. After assembly the
two support rods will have to be set into the ground on even keel with concrete.
For safety reasons, the grab poles must be set in concrete precisely as shown in
figure 6. Concrete mixture is not part of the product and will have to be purchased
separately. Follow the concrete manufacturer's instructions to mix it properly.
MAINTENANCE AND STORAGE
Use a dry or damp cloth only to clean the product; do not use special cleaning
agents! Check the product for damage or traces of wear and tear before and after
each use. Do not make any structural changes. For your own safety, please use
original spare parts only. These can be sourced from HUDORA. If parts become
damaged or if sharp edges or corners should develop, the product may not be
used any more. If in any doubt, please contact our service team (www.hudora.de).
Store the product in a safe place where it is protected from the elements, cannot be
damaged, and cannot injure anyone.
After you have assembled all components, make sure that all screw connections
are tight. Check nuts and screws regularly for tightness and tighten if necessary.
We also recommend before each use to check all coverings for bolts and sharp
edges and replace when required. If possible, cover the gymnastics high bar with a
tarpaulin. It will provide protection against harsh weather conditions.
DISPOSAL ADVICE
At the end of the product's life, please dispose of it at an appropriate collection point
provided in your area. Local waste management companies will be able to answer
your questions on this.
SERVICE
We make every effort to deliver faultless products. If faults do arise however, we
put just as much effort into rectifying them. Therefore, you can find numerous
information on the product, replacement parts, solutions to problems and lost
assembly manuals at www.hudora.de.
6/16