Prevent Damage From Chemical Supplies And Chemical Systems; How Chemical Supplies Can Cause Damage; Dangerous Chemical Supplies And Wash Formulas; Incorrect Configuration Or Connection Of Equipment - Milnor 42044CP2 Mantenimiento

any other overriding standard.
WARNING 18 : Confined Space Hazards—Confinement in the cylinder can kill or injure
you. Hazards include but are not limited to panic, burns, poisoning, suffocation, heat prostration,
biological contamination, electrocution, and crushing.
• Do not enter the cylinder until it has been thoroughly purged, flushed, drained, cooled,
and immobilized.
BIWUUI06 (Published)
2.2. Prevent Damage From Chemical Supplies and Chemical
Systems
This document uses Simplified Technical English.
Learn more at http://www.asd-ste100.org.
®
All Milnor washer-extractors and CBW
specification. This material gives good performance when chemical supplies are correctly applied.
If chemical supplies are incorrectly applied, this material can be damaged. The damage can be
very bad and it can occur quickly.
Chemical supply companies usually:
• supply chemical pump systems that put the supplies in the machine,
• connect the chemical pump system to the machine,
• write wash formulas that control the chemical concentrations.
The company that does these procedures must make sure that these procedures do not cause
damage. Pellerin Milnor Corporation accepts no responsibility for chemical damage to the
machines it makes or to the goods in a machine.

How Chemical Supplies Can Cause Damage

2.2.1.

Dangerous Chemical Supplies and Wash Formulas

2.2.1.1.
cause damage are:
• a very high concentration of chlorine bleach,
• a mixture of acid sour and hypo chlorite,
• chemical supplies (examples: chlorine bleach, hydrofluosilicic acid) that stay on the stainless
steel because they are not quickly flushed with water.
The book "Textile Laundering Technology" by Charles L. Riggs gives data about correct
chemical supplies and formulas.

Incorrect Configuration or Connection of Equipment

2.2.1.2.
• do not prevent a vacuum in the chemical tube (for example, with a vacuum breaker) when the
pump is off,
• do not prevent flow (for example, with a valve) where the chemical tube goes in the machine.
Damage will occur if a chemical supply can go in the machine when the chemical system is off.
Some configurations of components can let the chemical supplies go in the machine by a siphon
(Figure 2). Some can let chemical supplies go in the machine by gravity
— End of BIUUUS27 —
Book specs- Dates: 20120626 / 20120626 / 20140710 Lang: ENG01 Applic: HD4
®
tunnel washers use stainless steel with the AISI 304
17
Chapter 2. Safety
—Some examples that can
—Many chemical systems:
(Figure 3).
PELLERIN MILNOR CORPORATION