Inspection And Testing - Stryker 242-000-012 Guia Del Usuario

3.Cleaning.was.validated.using.
Enzol®.at.1.oz/gal.
4.Cleaning.was.validated.using.
Renu-Klenz™.at.¼.oz/gal.
Maintenance
Inspection and
Testing
Packaging for
Sterilization
EN-8
2
•. Program.the.washer.using.the.settings.below.
Recirculation
Pre Wash
Enzyme
Wash
Wash 1
Rinse 1
Dry Phase
3
•. Remove.the.tray.from.the.washer.after.the.
•. Dry.the.tray.using.a.clean.soft.cloth..Use.filtered.
•. Visually.inspect.the.tray.for.cleanliness,.paying.
•. No.routine.maintenance.is.required.for.the.
•. Inspect.the.tray.for.dents.and.cracks..If.a.
•. Inspect.all.components.for.cleanliness..If.fluid.
•. Double-wrap.the.tray.unless.otherwise.noted.
Automated wash
Time Temperature
2.min. Cold.tap.water
2.min. Hot.tap.water
2.min. Set.point.60°C
2.min.
7.min. Drying Temperature
Drying
completion.of.the.dry.phase.
pressurized.air.(40.psi).to.assist.in.drying.
close.attention.to.hard-to-reach.areas.
sterilization.tray.
problem.is.observed.or.suspected,.the.tray.
should.be.returned.for.repair.
or.tissue.buildup.is.present,.repeat.the.above.
cleaning.and.disinfection.procedures.
below.
Water
(140°F)
Heated.60°C
(140°F)
115°C.(239°F)
Detergent
(type and
concentration)
—
Enzymatic.
Detergent3
Non-enzymatic.
Detergent4
—
—