Whirlpool Acros AF30212 Instructivo De Instalación, Uso Y Manejo página 5

If the installation is not
new, you should clean
it in order to avoid the
obstruction of orifices
and/or pilots.
I M P O R T A N T
• This range is adjusted at the factory
for use with L.P. gas.
• To use this range with natural gas,
you must replace the surface and
oven burner orifices, call Servicio
Acros-Whirlpool, the phone number
is shown in the page 14. The
technician must make sure that the
connections have no leaks and the
gas pressure in the range is the
same as shown in the charts.
How to Use Your Range
HOW TO ADJUST THE FLAMES
If the range has yellow flames, it may
require adjustment to the air shutters:
• How to adjust the air for surface burners:
1
Remove the
knobs.
LP GAS OPERATING PRESSURE
11 in WATER COLUMN
(6,36 oz/squared inch)
BURNER
UPPER STAMPED
CENTRAL STAMPED
UPPER STD ALUM.
UPPER SUPER ALUM.
OVEN
NATURAL GAS OPERATING
PRESSURE 7 in WATER COLUMN
(4,04 oz/squared inch)
BURNER
UPPER STAMPED
CENTRAL STAMPED
UPPER STD ALUM.
UPPER SUPER ALUM.
OVEN
NOTE: To operate this range with natural gas,
is required a kit according to the chart:
This kit is available at your nearest Authorized Service
Center.
2
Unscrew the screws
of front and below the
manifold panel and
remove it.
To make it easier to move the
appliance, the installer should
loop the 3/8" copper tubing as
shown in the illustration.
LP Gas to
Range Model
Natural Gas
Model AF30850 98014567
Model AF30548 98014567
Model AF30700 98014567
Model AF30547 98014567
Model AF30500 98016221
Model AF30600 98014567
Model AF30439 98014571
Model AF30437 98014566
Model AF30550 98014566
Model AF30434 98016221
Model AF30200 98016858
Model AF30314 98016221
Model AF30212 98014528
NOTE: Do not obstruct the gas
exhaust of the oven or broiler
NOTE: Because of different altitudes above
sea level and variations in the supply of gas,
you may need to adjust the main air intake
to the burners. This will result in a better
air-gas mixture and thus a better operation.
3
THERMAL
ORIFICE
ORIFICE
CAPACITY
DIAMETER
NUMBER INCHES
68 0,031
66 0,033
68 0,031
64
0,036
57 0,043
THERMAL
ORIFICE
ORIFICE
CAPACITY
DIAMETER
NUMBER
INCHES
58
0,042
56
0,046
58
0,042
55 0,052
52
0,063
Natural Gas to
LP Gas
98015918
98015918
98015918
98015918
98016222
98015918
98014290
98014283
98014283
98016222
98016859
98016222
98015926
Adjust the air shutters
individually. Light the
burner, then push or pull
the air shutter until you
get a blue flame that will
not cause the flame to
lift or blow off the burner.
BTU/h
6 500
7 500
6 700
9 000
13 000
BTU/h
6 500
7 500
6 700
9 000
13 000
5