Tabla De Contenido - Generac G0062700 Directrices De Instalación

Section 1: Safety Rules & General
Information
Introduction ..........................................................1
Read This Manual Thoroughly ....................................1
How to Obtain Service .................................................1
Safety Rules .........................................................1
General Hazards .........................................................2
Exhaust Hazards .........................................................3
Electrical Hazards .......................................................3
Fire Hazards ................................................................3
Explosion Hazards ......................................................4
General Rules .......................................................4
Before You Begin ........................................................5
NEC Requirements .....................................................5
Standards Index ..........................................................5
Section 2: Unpacking and Inspection
General .................................................................7
Required Tools .....................................................7
Unpacking ............................................................7
Parts Shipped Loose ...........................................9
Section 3: Site Selection and Preparation
Site Selection .....................................................11
Installation Guidelines for Stationary Air-Cooled
Generators .............................................................12
Site Preparation .................................................13
Material Sufficient for Level Installation .....................13
Transportation Recommendations ............................13
Section 4: Generator Placement
Generator Placement .........................................15
Fascia Installation (If Applicable) .....................15
Section 5: Fuel Conversion/Gas
Connections
Fuel Conversion .................................................17
Fuel Requirements and Recommendations ....17
Fuel Consumption .............................................18
Fuel Line Sizing .................................................19
Natural Gas Pipe Sizing ............................................19
LP Vapor Pipe Sizing ................................................19
Gas Installation Summary .........................................19
Installation Guidelines For 50 Hz Air-Cooled Generators
Table of Contents
Installing and Connecting Gas Lines .............. 20
Natural Gas Vapor Installation (typical) .......... 21
LP Vapor Installation (typical) .......................... 22
Section 6: Electrical Connections
Generator Connections .................................... 23
Control Wiring ................................................... 23
Main AC Wiring .................................................. 24
Battery Requirements ....................................... 24
Battery Installation ............................................ 24
Section 7:Control Panel/Start-Up/Testing
Control Panel Interface ..................................... 25
Using the AUTO/MANUAL/OFF Buttons ..................25
Generator Set-Up ............................................... 25
Set Voltage ................................................................25
Cold Smart Start ........................................................25
Setting The Exercise Timer .......................................25
Before Initial Start-up ........................................ 26
Installation Wizard .....................................................26
Interconnect System Self Test Feature .....................27
Before starting, complete the following: ....................27
Check Manual Transfer Switch Operation ...... 27
Electrical Checks ............................................... 27
Generator Tests Under Load ............................ 28
Checking Automatic Operation ........................ 28
Installation Summary ........................................ 28
Shutting Generator Down While Under Load . 29
Section 8:Troubleshooting / Quick
Troubleshooting ................................................ 31
Quick Reference Guide ..................................... 32
Section 9: Accessories
Descriptions ....................................................... 35
Section 10: Diagrams
Interconnection Diagram .................................. 37
Installation Diagram .......................................... 38
Reference Guide
iii