Mitt 125 GP2 Manual De Usuario página 43

Tabla de solución de problemas del motor
Trouble
Engine start failure
or flames out easily
after its startup
Ruido anormal
Desde el motor
Inestable
motor
operacion
consumo
excesivo
MITT MOTORCYCLES. TODOS LOS DERECHOS RESERVADOS / ALL RIGHT RESERVED. WWW.MITTMOTORS.COM
Cause
from Ⅱ.2 Diagnosis and troubleshooting of
See
fault without fault code of
Section 3: Electronic Fuel Injection System,
1、 Serious worn
cylinder and piston
2、 Serious worn out needle
bearings in small and big
ends of connecting rod
3、 Premature ignition
4、 Excessive carbon deposit
in combustion chamber
5、 Overheated spark plug
1、 Water or dirt in carburetor
2、 Clogged fuel passage
3、 Leaking crankcase
4、 Leaking
between Throttle
engine
5、 Over-rich or over-thin gas
mixture
1、 Low gear driving over a
long time
2、 Over loaded driving or 2、Control
heavy load
3、 Unqualified engine oil or
insufficient transmission oil
4、 Slipping clutch
5、 Too tight chain
6. Unreleased brake
41
Chapter4
out 1、 Replace cylinder body and
piston
2、 Replace bearing and relate
parts
3、 Adjust ignition time
4、 Clean out carbon deposit
5、 Replace spark plug
1、limpie el carburador
2、 Clean or replace fuel pipe
3、 Replace sealing
connection 4、 Tighten screw
and 5、 Adjust carburetor
1、Change gear position and
control time
cooling
3、Replace
engine oil and fill oil to
transmission case
4、Adjust free play or
replace clutch , friction
lining and spring
5、Adjust tension
6.Adjust brake clearance
Remedy
load-carrying and
with qualified