Transmission Oil - Malaguti Madison3 125ie Manual De Uso

5.3 TRANSMISSION OIL

Check level every 10,000 km (6,200 mi) or 20 months
6,000 km (3,720 mi) or 12 months for 125cc version
1) Place vehicle on a level surface on its centre stand.
2) Unscrew dipstick (A - Fig. 26), clean it and refit it, wrenching it
tightly.
3) Pull it out again and check that oil level is between MIN and
1
MAX notches.
4) If level is insufficient, top up until oil is touching MAX notch.
5) Fill crankcase with oil of following type: Q8 T35 - 80W
2 Crankcase capacity approx.: 250 cm
Renew after first 1,000 km (620 mi) and
3
every 20,000 km (12,400 mi)
after first 1,000 km (620 mi) and
every 24,000 km (14,800 mi) for 125cc version
4
• Carry out operations described above at points 1-2, without
refitting dipstick; then put a container under engine crankcase
and unscrew drain screw (B - Fig. 27), paying attention to gas-
ket.
5
• Let oil flow into container (pay attention to avoid scorching).
• Refit drain screw with gasket and fill with approximately 250 cm
(150 cm 3 for 125cc version) of new oil (Q8 T35 - 80W), then refit
cap and dipstick (A - Fig. 26).
6
• Now repeat checks 3-4-5.
If the drain screw gasket is damaged, replace it.
Regularly check for oil leakages near drain screw at the
rear wheel. If you notice any leaks, contact an Author-
ised MALAGUTI Service Centre.
34
3 3
(150 cm for 125cc version)
3
A
Prevent foreign matters from getting into transmission
crankcase during checks or oil changes. Prevent oil drip-
ping on tires or wheels.
ENGLISH
MAX 250
MAX 125
Fig. 26
B
Fig. 27