Safety Precautions - Mitsubishi Electric PUZ-A18-NHA6 Para El Instalador

1. Safety precautions

1.3. Before electric work
Caution:
‡ %H VXUH WR LQVWDOO FLUFXLW EUHDNHUV ,I QRW LQVWDOOHG HOHFWULF VKRFN PD\ UHVXOW
‡ )RU WKH SRZHU OLQHV XVH VWDQGDUG FDEOHV RI VXI¿FLHQW FDSDFLW\ 2WKHUZLVH D
VKRUW FLUFXLW RYHUKHDWLQJ RU ¿UH PD\ UHVXOW
‡ :KHQ LQVWDOOLQJ WKH SRZHU OLQHV GR QRW DSSO\ WHQVLRQ WR WKH FDEOHV ,I WKH
connections are loosened, the cables can snap or break and overheating or
¿UH PD\ UHVXOW
 %HIRUH VWDUWLQJ WKH WHVW UXQ
Caution:
‡ 7XUQ RQ WKH PDLQ SRZHU VZLWFK PRUH WKDQ  KRXUV EHIRUH VWDUWLQJ RSHUD-
tion. Starting operation just after turning on the power switch can severely
damage the internal parts. Keep the main power switch turned on during the
operation season.
‡ %HIRUH VWDUWLQJ RSHUDWLRQ FKHFN WKDW DOO SDQHOV JXDUGV DQG RWKHU SURWHFWLYH
parts are correctly installed. Rotating, hot, or high voltage parts can cause
injuries.
‡ 'R QRW WRXFK DQ\ VZLWFK ZLWK ZHW KDQGV (OHFWULF VKRFN PD\ UHVXOW
 8VLQJ 5$ UHIULJHUDQW DLU FRQGLWLRQHUV
Caution:
‡ 8VH & FRSSHU SKRVSKRUXV IRU FRSSHU DQG FRSSHU DOOR\ VHDPOHVV SLSHV
to connect the refrigerant pipes. Make sure the insides of the pipes are clean
and do not contain any harmful contaminants such as sulfuric compounds,
R[LGDQWV GHEULV RU GXVW 8VH SLSHV ZLWK WKH VSHFL¿HG WKLFNQHVV 5HIHU WR
SDJH  1RWH WKH IROORZLQJ LI UHXVLQJ H[LVWLQJ SLSHV WKDW FDUULHG 5 UHIULJHU-
ant.
 5HSODFH WKH H[LVWLQJ ÀDUH QXWV DQG ÀDUH WKH ÀDUHG VHFWLRQV DJDLQ
- Do not use thin pipes. (Refer to page 5)
‡ 6WRUH WKH SLSHV WR EH XVHG GXULQJ LQVWDOODWLRQ LQGRRUV DQG NHHS ERWK HQGV RI
the pipes sealed until just before brazing. (Leave elbow joints, etc. in their
packaging.) If dust, debris, or moisture enters the refrigerant lines, oil dete-
rioration or compressor breakdown may result.
‡ 8VH HVWHU RLO HWKHU RLO DON\OEHQ]HQH RLO VPDOO DPRXQW DV WKH UHIULJHUDWLRQ
RLO DSSOLHG WR WKH ÀDUHG VHFWLRQV ,I PLQHUDO RLO LV PL[HG LQ WKH UHIULJHUDWLRQ
oil, oil deterioration may result.
 ,QVWDOODWLRQ ORFDWLRQ
D
B
$ $
(inch)
)LJ 
A
E
C
)LJ 
$ $ $ $
‡ %H VXUH WR JURXQG WKH XQLW 'R QRW FRQQHFW WKH JURXQG ZLUH WR JDV RU ZDWHU
pipes, lighting rods, or telephone grounding lines. If the unit is not properly
grounded, electric shock may result.
‡ 8VH FLUFXLW EUHDNHUV JURXQG IDXOW LQWHUUXSWHU LVRODWLQJ VZLWFK % IXVH  DQG
PROGHG FDVH FLUFXLW EUHDNHU ZLWK WKH VSHFL¿HG FDSDFLW\ ,I WKH FLUFXLW EUHDNHU
FDSDFLW\ LV ODUJHU WKDQ WKH VSHFL¿HG FDSDFLW\ EUHDNGRZQ RU ¿UH PD\ UHVXOW
‡ 'R QRW WRXFK WKH UHIULJHUDQW SLSHV ZLWK EDUH KDQGV GXULQJ RSHUDWLRQ 7KH
UHIULJHUDQW SLSHV DUH KRW RU FROG GHSHQGLQJ RQ WKH FRQGLWLRQ RI WKH ÀRZLQJ
refrigerant. If you touch the pipes, burns or frostbite may result.
‡ $IWHU VWRSSLQJ RSHUDWLRQ EH VXUH WR ZDLW DW OHDVW ¿YH PLQXWHV EHIRUH WXUQ-
ing off the main power switch. Otherwise, water leakage or breakdown may
result.
‡ 'R QRW XVH UHIULJHUDQW RWKHU WKDQ 5$ UHIULJHUDQW ,I DQRWKHU UHIULJHUDQW LV
used, the chlorine will cause the oil to deteriorate.
‡ 8VH WKH IROORZLQJ WRROV VSHFL¿FDOO\ GHVLJQHG IRU XVH ZLWK 5$ UHIULJHUDQW
7KH IROORZLQJ WRROV DUH QHFHVVDU\ WR XVH 5$ UHIULJHUDQW &RQWDFW \RXU
nearest dealer for any questions.
Gauge manifold
Charge hose
Gas leak detector
Torque wrench
‡ %H VXUH WR XVH WKH FRUUHFW WRROV ,I GXVW GHEULV RU PRLVWXUH HQWHUV WKH UHIULJ-
erant lines, refrigeration oil deterioration may result.
‡ 'R QRW XVH D FKDUJLQJ F\OLQGHU ,I D FKDUJLQJ F\OLQGHU LV XVHG WKH FRPSRVL-
WLRQ RI WKH UHIULJHUDQW ZLOO FKDQJH DQG WKH HI¿FLHQF\ ZLOO EH ORZHUHG
 5HIULJHUDQW SLSH )LJ 
Check that the difference between the heights of the indoor and outdoor
units, the length of refrigerant pipe, and the number of bends in the pipe are
within the limits shown below.
Models
PUZ-A18
PUZ-A24, A30, A36, A42 Max. 50 m, 165 ft
PUY-A12, A18
PUY-A24, A30, A36, A42 Max. 69 m, 225 ft
‡ +HLJKW GLIIHUHQFH OLPLWDWLRQV DUH ELQGLQJ UHJDUGOHVV RI ZKLFK XQLW LQGRRU RU RXW-
door, is positioned higher.
D Indoor unit
E Outdoor unit
(inch)
 &KRRVLQJ WKH RXWGRRU XQLW LQVWDOODWLRQ ORFDWLRQ
‡ $YRLG ORFDWLRQV H[SRVHG WR GLUHFW VXQOLJKW RU RWKHU VRXUFHV RI KHDW
‡ 6HOHFW D ORFDWLRQ IURP ZKLFK QRLVH HPLWWHG E\ WKH XQLW ZLOO QRW LQFRQYHQLHQFH QHLJK-
bors.
‡ 6HOHFW D ORFDWLRQ SHUPLWWLQJ HDV\ ZLULQJ DQG SLSH DFFHVV WR WKH SRZHU VRXUFH DQG
indoor unit.
‡ $YRLG ORFDWLRQV ZKHUH FRPEXVWLEOH JDVHV PD\ OHDN EH SURGXFHG ÀRZ RU DFFXPX-
late.
‡ 1RWH WKDW ZDWHU PD\ GUDLQ IURP WKH XQLW GXULQJ RSHUDWLRQ
‡ 6HOHFW D OHYHO ORFDWLRQ WKDW FDQ EHDU WKH ZHLJKW DQG YLEUDWLRQ RI WKH XQLW
‡ $YRLG ORFDWLRQV ZKHUH WKH XQLW FDQ EH FRYHUHG E\ VQRZ ,Q DUHDV ZKHUH KHDY\
snow fall is anticipated, special precautions such as raising the installation location
or installing a hood on the air intake must be taken to prevent the snow from block-
LQJ WKH DLU LQWDNH RU EORZLQJ GLUHFWO\ DJDLQVW LW 7KLV FDQ UHGXFH WKH DLUÀRZ DQG D
malfunction may result.
‡ $YRLG ORFDWLRQV H[SRVHG WR RLO VWHDP RU VXOIXULF JDV
‡ 8VH WKH WUDQVSRUWDWLRQ KDQGOHV RI WKH RXWGRRU XQLW WR WUDQVSRUW WKH XQLW ,I WKH XQLW LV
FDUULHG IURP WKH ERWWRP KDQGV RU ¿QJHUV PD\ EH SLQFKHG
 2XWOLQH GLPHQVLRQV 2XWGRRU XQLW )LJ 
7KH ¿JXUH LQ SDUHQWKHVLV LV IRU $ PRGHO
Tools (for R410A)
Flare tool
Size adjustment gauge
Vacuum pump adapter
Electronic refrigerant charging scale
APipe length BHeight
( (one way) y) difference
Max. 30 m, 100 ft Max. 30 m,100 ft
Max. 30 m,100 ft
Max. 50 m, 165 ft Max. 30 m,100 ft
Max. 30 m,100 ft
CNumber of
bends (one way) ( y)
Max. 15
Max. 15
Max. 15
Max. 15
3