Troubleshooting Guide - Altrad Belle PCX 17/50A Manual Del Operador

WARNING
Honda GX120 & GX160
fully to the left. If restarting a warm engine, the choke is usually not required,
however, if the engine has cooled to a degree, partial choke may be required.
4. Set the throttle to the idle position by moving the throttle lever fully to the right. Do
not start the engine on full throttle, as the compactor will vibrate as soon as the
engine starts.
handle with the other. Pull the recoil starter until engine resistance is felt, then let
starter return.
Problem
Engine will not start.
Engine still will not start.
Unit will not vibrate.
Asphalt adhering to plate.
Low travel speed (plate sinking).
Operating Instructions
Before you operate or carry out any maintenance on this machine YOU MUST READ and STUDY
this manual.

Troubleshooting Guide

Cause
No fuel.
Engine switched off.
Spark plug fouled.
Engine cold.
Major Fault
Engine speed too slow.
Drive belt tension loose.
Drive failure.
Vibrator failure.
Over compaction.
Moisture content too high or too low.
Remedy
Open fuel tap.
Fill fuel tank.
Switch engine on.
Clean and reset plug gap.
Close choke.
Honda, open choke, fully open throttle, pull
Contact Agent or Altrad Belle.
Set engine speed control to fast.
Adjust belt tension.
Contact Agent or Altrad Belle.
Contact Agent or Altrad Belle.
Use a water spray system.
Remove and relay.
Remove some of the material.
Remove material and adjust.
11
GB
Throttle Lever
Choke Lever
Fuel ON/OFF
Lever.
GB