Tabla De Contenido - Generac 0060550 El Manual Del Propietario

Section 1: Safety Rules
Introduction ..................................................................1
Read This Manual Thoroughly ....................................1
How to Obtain Service .................................................1
Safety Rules .................................................................2
General Hazards .........................................................2
Exhaust Hazards .........................................................3
Electrical Hazards .......................................................3
Fire Hazards ................................................................4
Explosion Hazards ......................................................4
Section 2: General Information
Synergy Operating Principle .......................................5
Benefits .......................................................................5
Start Up .......................................................................5
Normal Running ..........................................................5
Small Load Changes ...................................................5
Large Load (Not Overload) ..........................................5
Overload ......................................................................5
Low Speed Exercise ....................................................5
Normal Exercise ..........................................................5
Automatic Voltage Regulator (AVR) Cooling Fans ......5
Protection Systems .....................................................7
Emissions .....................................................................7
Specifications ...............................................................8
Generator ....................................................................8
Engine .........................................................................8
Fuel Requirements .......................................................9
Battery Requirements ..................................................9
Battery Charger ............................................................9
Engine Oil Requirements ............................................9
Replacement Parts .......................................................9
Accessories ................................................................10
Section 3: Operation
Site Prep Verification .................................................11
Side Compartment .....................................................11
Main Circuit Breaker (Generator Disconnect) ............11
LED Indicator Lights ..................................................11
120V GFCI Outlet/15 Amp Breaker ...........................11
Generator Enclosure .................................................11
Control Panel Interface ..............................................13
Using the Auto/Off/Manual Interface ........................13
Owner's Manual for 60 Hz Synergy Generator™
Table of Contents
Interface Menu Displays ............................................13
The LCD display ........................................................13
Menu System Navigation ..........................................13
Setting the Exercise Timer ........................................16
Battery Charger ..........................................................16
Manual Transfer Operation .......................................17
Transfer to Generator Power Source ........................17
Transfer Back to Utility Power Source .......................17
Automatic Transfer Operation ..................................18
Automatic Sequence of Operation ...........................18
Utility Failure ..............................................................18
Cranking ....................................................................18
Cold Smart Start ........................................................18
Load Transfer ............................................................18
Shutting Generator Down While Under Load ..........19
To turn the generator OFF: .......................................19
To turn the generator back ON: .................................19
Section 4: Maintenance
Maintenance ...............................................................21
Performing Scheduled Maintenance ........................21
Before Servicing ........................................................21
Maintenance Kits .......................................................21
Service Schedule .......................................................22
Maintenance Log .......................................................23
Oil, oil filter, air filter and spark plug replacement .....23
Valve Adjustment ......................................................23
Checking Engine Oil Level ........................................23
Engine Oil Recommendations ...................................23
Changing the Oil and Oil Filter .................................24
Replacing the Engine Air Filter .................................25
Replacing the AVR Filter ...........................................25
Maintaining the Spark Plugs .....................................26
Valve Clearance Adjustment .....................................26
Check Valve Clearance .............................................26
Adjust Valve Clearance .............................................27
Battery Maintenance ..................................................28
Attention After Submersion ......................................28
Corrosion Protection .................................................29
Remove From, and Return To Service Procedure ..29
Remove From Service ...............................................29
Return to Service .......................................................29
iii