Hudora 65400/03 Instrucciones De Montaje página 11

INSTRUCTIONS ON ASSEMBLY AND USE
EN
STEP 3: ASSEMBLING THE FRAME PADDING (Fig. 3.1 – 3.3)
a) Place the frame padding (2) towards the trampoline, so that the coil springs
and the steel frame are covered. Make sure that the frame padding covers all
metal parts. Place the elastic drawstrings so that every other string is led over
a leg socket.
b) First fasten the drawstrings at the back of the leg sockets. (Fig. 3.2)
c) Tighten the elastic drawstrings that are not positioned over a leg socket (Fig.
3.3), so that the frame padding covers the frame. Knot the two ends together.
STEP 4: ASSEMBLY OF THE NET RODS (Fig. 4.1 & Fig. 4.2)
Follow the assembly steps in Fig. 4.1 and 4.2. Ensure that the screw connec-
tion is fastened hand tight. Ensure that the foam tube is positioned above the
trampoline frame.
STEP 5: SUSPENDING OF THE NET (Fig. 5).
Attach the safety net (12) as shown with the network loops (18) at the tube end
caps (11). Ensure that the bracket of the tube end cap is facing outwards. Make
sure that the position of the net entry is aligned with the boarding aid.
STEP 6: FASTENING THE NET TO THE JUMPING MAT (Fig. 6)
Knot the tether (14) on a eyelet of the spring mat. Then thread it as shown alter-
nately through the eyelet of the spring mat and through the safety net (12). The
tensioning cable is divided into several parts for easy assembly. Pay attention
to a complete assembly. When you get back to the starting eyelet, knot the end
again. NOTE: for the purpose of better visibility, the frame padding is not shown
in the image.
STEP 7: ALIGNING THE SAFETY NET (Fig. 7)
Pull the zipper of the safety net (12), which must lie between two leg sockets of
the trampoline, at the inlet closed and then release the two latches into place.
IMPORTANT WARNING! All snap closures must be once again clamped secu-
rely so that the safety net becomes taut. If the safety net is not taut, it cannot
complete its function as designed. Tighten all locking nuts last once all setup
is complete.
MOVING THE TRAMPOLINE
In order to move the trampoline you should have as many helpers as the tram-
poline has feet. Prior to lifting, all used fasteners (pegs, etc.) should be removed.
Caution! Due to the spring tension there is a possible risk that the frame can
be twisted into a figure „8" as a result of uneven lifting! You and your helpers
should therefore be respectively positioned between two feet of the trampoline
and you should then all lift the trampoline at the same time. Lift the trampo-
line off the ground slightly and keep it horizontal with the floor. To move the
trampoline in a different way, disassemble it completely. To disassemble, follow
instructions for assembly backwards.
MAINTENANCE AND STORAGE
Use a dry or damp cloth only to clean the product; do not use special cleaning
agents! Check the product for damage or traces of wear and tear before and
after each use. Do not make any structural changes. For your own safety, please
use original spare parts only. These can be sourced from HUDORA. If parts
become damaged or if sharp edges or corners should develop, the product may
not be used any more. If in any doubt, please contact our service team (http://
www.hudora.de/). Store the product in a safe place where it is protected from
the elements, cannot be damaged, and cannot injure anyone.
• Check that jumping mat, side padding and enclosure are without defects and
can withstand load. Sunlight, rain, snow and extreme temperatures will make
these parts lose strength. Replace jumping mat, side padding and enclosure
after 36 month use.
• Check the product regularly - especially before and after use! - for damage
and wear marks. Not servicing the product regularly can lead to dangerous
consequences for the user.
• Verify prior to each use that the trampoline mat is not worn and parts are
not loose or missing. In particular, check all spring and bolt connections and
tighten them if necessary, so that they do not loosen during use.
• Strong winds can blow off the trampoline. If strong winds are expected, then
use the trampoline in a sheltered area or take it off altogether. Another option
is to secure the trampoline by winding a rope around it (upper part) taking
care to anchor the rope at a minimum of three places on the surface on which
the trampoline is standing. Do not tie down the trampoline only by its legs as
it can cause the frame joints to come apart.
• Keep the trampoline safe from impermissible access when not in use. For
trampoline with ladders, the supervisor must remove the ladder when leaving
the place so that unsupervised children under 6 years do not get on the
trampoline.
• Make sure that the padding for the trampoline frame is attached securely and
is at the right place.
• In order to keep the risk of an injury to the minimum, always check the
trampoline for worn, defective or missing parts before use.
• Always inspect the safety net to find out if it is worn out or damaged before
the trampoline is used. Make sure that the safety net is properly attached, its
straps are securely fastened and the safety net itself is not damaged.
• Put the trampoline away when it is not to be used.
• Do not make any technical modifications. The trampoline and its safety net
should be dismantled or secured against use until necessary corrections have
been made, if a fault or an abnormality which is potentially dangerous to the
user has been detected.
• Do not use the trampoline if it is damaged or unsafe!
WATCH OUT FOR THE FOLLOWING
• Tears, holes or rips
• Loose jumping mat
• Pulled seams or other closure problems
• Bent or broken framework, i.e. legs
• Damaged or loose screws
• Broken, missing or damaged springs
• Damaged, missing or unsecured frame cushion
• Protruding objects of any kind (especially sharp edges) on the frame, springs
or the mat
DISPOSAL ADVICE
At the end of the product's life, please dispose of it at an appropriate collection
point provided in your area. Local waste management companies will be able to
answer your questions on this.
SERVICE
We make every effort to deliver faultless products. If faults do arise however, we
put just as much effort into rectifying them. Therefore, you can find numerous
information on the product, replacement parts, solutions to problems and lost
assembly manuals at http://www.hudora.de/.
SAFE USE
• Be aware of the fact that a trampoline's connecting springs can generate
tremendous elasticity and propel the person on the mat to surprising heights
and cause the body to move in a variety of extreme and unusual directions.
Use the trampoline only if you are physically fit. In case of a doubt, consult a
doctor before using the product.
• Stop jumping if you have moved more than 30 cm from the logo. Get back to
the centre of the mat and on the logo to resume jumping.
• To stop jumping, bend your knees when your feet come in contact with the
mat. Master this technique before trying newer ones.
• Master basic jumps before trying advanced skills. You can combine these
basic moves in a variety of combinations with or without straight intermediate
jumps to carry out various sequences on the trampoline.
• Avoid jumping too high. Keep your jumps low till you have sufficient control
on your jumps and always land on the middle of the trampoline. Controlled
jumping is more important than height. Keep your eyes on the trampoline as
it helps to control the jumps.
• Do not jump from balconies, trees or other such high places on to the
trampoline. Do not use the trampoline as a springboard. Jumps should never
be higher than the safety net.
• Do not jump deliberately or bounce off the safety net. Do not hang from the
top of the safety net or try to climb it. Remove all jewellery as it may get
caught or cut through the safety net.
• Contact an authorised trampoline coach for information on advanced skills.
11/24