Troubleshooting - Sabo 72-12G Manual De Uso

TROUBLESHOOTING

7. TROUBLESHOOTING
PROBLEM SITUATION
1. Pilot lamp off Key is in «ON»
position,
engine
stopped
2. Starter motor Key in
not working «START» posi-
tion and pilot
lamp on
Key in
«START» posi-
tion and pilot
lamp flashing
3. Engine does Key in
not start «START» posi-
tion
4. Starting is dif- Key in «ON»,
ficult or the engine running
engine runs
erratically
LIKELY CAUSE
Electronic card in safety alert, due
to:
– badly connected battery
– completely flat battery or eroded
battery plates
– battery terminals crossed
– fuse blown
– badly earthed
– electronic card wet
– earthed micro-switches
– insufficiently charged battery
– battery charger fuse blown
– badly earthed
– you are not ready for starting
– no fuel supply
– faulty ignition
– fuel fault
SOLUTIONS
Put the key in the «OFF» posi-
tion and look for the cause of
the problem:
– check connections
– recharge battery
– connect properly
– replace fuse (10 A)
– check connections
– dry by air
– check connections
– recharge battery (if the
problem continues, consult
your Dealer)
– replace fuse (25 A)
– check connections
– Check that the conditions
allowing the start are met
(see page 26/a)
– check fuel level
– open fuel stop-cock
– check fuel filter
– check that spark plugs
caps are firmly fitted
– check that the electrodes
are clean and have the cor-
rect gap
– clean or replace the air filter
– flush out the float chamber
– empty fuel tank and refill
with new fuel
– check and, if necessary,
replace fuel filter
ENG 41