Safety And Health - Sagola DOBLE 250 Manual De Instrucciones

The unit should NEVER be used to clean or
degrease objects intended to be in contact with
food.
The room should be supplied with sufficient
ventilation and be in accordance with the current
legislation and regulations in this respect. In the
same way, all established legislative methods
concerning the health of and prevention of work
risk to operators should be made available.
Never raise the indicated work pressure. The unit
is calibrated by the manufacturer, in accordance
with the design specifications described in the
characteristics of the same.
The unit environment should only contain the
quantity of product necessary for the work being
carried out.
After finalising the same, the unused products
should be returned to their specific storage place.
Keep the work area clean and free from potentially
dangerous waste (thinners, rags, etc...). During
the work and in the work area, no ignition source
should exist (open fire, lit cigarettes, etc.), as easily
inflammable gases can be generated during the
same. Likewise, work protection approved in
accordance with the established Regulations in
this respect should be used.
If the unit is used in an inadequate manner or its
components are altered in any way, severe material
damage may occur and bodily harm may be
caused to the operator, other personnel and/or
animals and may even cause death.SAGOLA,
S.A. accepts no responsibility in for any damage
caused through the incorrect use of the unit.
Always use approved breathing units in
accordance with current Standards and Regulations
in order to protect yourself from emissions produced
the work.
As a general preventative measure, it is advisable
to use protective goggles, in accordance with the
specific environmental
characteristics for the Work Centre.
Use gloves.
If during use of the washing machine, the
environmental audible level rises over 90 dB, the
use of approved acoustic protectors is
recommended.

10. SAFETY AND HEALTH

regulations and
- 21 -
The washing machine in itself does not propitiate
any mechanical risk of perforations, impacts or
pinching, except those arising from improper
installations and handling.
USE SAGOLA ANTISTATIC HOSES TO ELIMINATE
POSSIBLE ELECTRICAL DISCHARGES, WHICH
COULD CAUSE FIRE OR EXPLOSION RISKS.
Pay adequate attention when handling the unit in
order to prevent any damage that might lead to
dangerous situations for the user or personnel
standing near the unit, as a consequence of leaks,
breakages, etc.
The washing machine has been designed for use
at room temperature. The maximum service
o
temperature is 50 C.
If products used in cleaning come into contact with
skin and eyes, wash with water and consult a
doctor.
IT IS ABSOLUTELY UNADVISABLE to use thinners
and/or detergents that contain halogenated
hydrocarbons (Trichloroethane, methyl Chloride,
etc.), which can cause chemical reactions in the
unit, as well as in its zinc coated components
(trichloroethane mixed with small quantities of
water produces hydrochloric acid). Due to this,
such components may rust and, in extreme cases,
the chemical reaction caused may be explosive.
Do not use acids, soda (alkalis or pickling
substances, etc.) for cleaning under any
circumstances.
In general, precautions must be taken whenever
the unit is handled, in order to prevent any
deterioration to it. Connectors must be securely
tightened and in good condition. Safety standards
should be understood and applied. Any
non-compliance with the indications set out in this
manual may lead to incidents affecting the physical
integrity of the user, other personnel or animals.
Respect and comply with indications relating to
the conservation of the environment.