Dust Emissions In The Environment; Ec Declaration Of Conformity; Packing And Unpacking - Nilfisk IVT1000 CR Manual De Instrucciones

Switch the motor off.
Put the upper part on the machine and secure with locking
clamp.
9 - Dustclasses
Classification in compliance with standard
EN 60335-2-69 – Annex AA
Vacuum cleaners for dust harmful to health are classified
according to the following dust classification:
■ L (low risk) suitable for separating dust with an exposure
limit value of over 1 mg/m
occupied;
M (medium risk) suitable for separating dust with
■
an exposure limit value of no lower than 0.1 mg/m
depending on the volume occupied;
■ H (high risk) for separating all dust with an exposure limit
value lower than 0.1 mg/m
occupied, including carcinogenic and pathogenic dusts,
such as asbestos.

9.1 - Dust emissions in the environment

Indicative values of performance:
■ version for dust harmful to health (Classes L, M, H):
L: retains at least 99% of the vacuumed particles
(see EN60335-2-69, Annex AA);
M: retains at least 99.9% of the vacuumed particles
(see EN60335-2-69, Annex AA);
H: retains at least 99.995% of the vacuumed
particles (see EN60335-2-69, Annex AA).
Figure 14
1. Class L label
2. Class M label
3.
Class H label
The class L and M labels contain pictograms with the
following meanings:
This vacuum cleaner contains dust hazardous for the health.
Only authorised personnel wearing suitable personal
protective equipment should empty and service the vacuum
cleaner, including removing the means used to
vacuum the dust. Do not use without the complete filter
system in place.
The class H label contains the above text.
This vacuum cleaner creates a strong air flow which is drawn
in through the inlet (10, Fig. 3) and blows out through the
exhaust (3, Fig. 3).
Before turning on the vacuum cleaner, fit the vacuum hose
into the inlet and then fit the required tool on to the end part.
Refer to the manufacturer's accessory catalogue or Service
Centre.
The diameters of the authorized hoses are indicated in the
Technical data table.
The vacuum cleaner is equipped with a main filter which
enables it to be used for the majority of applications.
C316
, depending on the volume
3
,
3
, depending on the volume
3
Besides the main filter which retains the more common types
of dust, the vacuum cleaner can be fitted with an upstream
absolute filter and a downstream absolute filter, with a higher
filtering capacity for fine dust and substances harmful for the
health.
NOTE
■ In the case of dust harmful to health, contact the local
health and safety authorities, and observe national
regulations in force both during use and disposal.
■ Radioactive substances are not included in the definition
of the type of dust harmful to health described above.

9.2 - EC Declaration of conformity

Every vacuum cleaner comes with a EC Declaration of
conformity. See fac-simile in fig. 13.
NOTE
The Declaration of conformity is an important document
and should be kept in a safe place to be presented to the
Authorities on request.
Accessories
Various accessories are available; refer to the manufacturer's
accessory catalogue.
WARNING
Use only genuine accessories supplied and authorised by the
manufacturer.

10 - Packing and unpacking

Dispose of the packing materials in compliance with the laws
in force.
Figure 15
MODEL
A (mm)
B (mm)
C (mm)
kg
Unpacking, moving, use and storage
Operate on flat, horizontal surfaces.
The load-bearing capacity of the surface the vacuum cleaner
is placed on must be suitable for bearing its weight.
11 - Maintenance
11.1 - Foreword
Attention!!
All maintenance and cleaning operations must be carried out
when the vacuum is off and disconnected from the electricity
main.
The suction unit needs no particular maintenance or lubrica-
tion.
Remember, however, that correct use and servicing arees-
sential if the safety and efficiency of the vacuum are to be
guaranteed.
16
IVT 1000 CR
400
400
810
14
07/2018