Tabla De Contenido; Introduction; System Components And Accessories; System Without Accessories - Carrier 80AW1 Manual De Instalación

Contents
Introduction ...........................................................................
System components and accessories .............................
System without accessories .........................................
System with accessories ................................................
System description .............................................................. 10-11
80AW1/80AWT ................................................................
80AW2 ................................................................................
Zone kits ........................................................................
Controller operation ............................................................ 14/16
Heating mode ................................................................... 14-15
Comfort mode .............................................................
Economy mode (ECO) ...............................................
Antifreeze protection mode (A_F) ........................
Cooling mode ...................................................................
Sanitary water mode ......................................................
Miscellaneous ...................................................................
Installation .............................................................................. 16/22
Unit dimensions and weights ......................................
Installation recommendations ....................................
Installation schemes .......................................................
Terminal types ............................................................

Introduction

The hydronic module is used to control heating or cooling
zones, each of which can be fan coil, underfl oor circuit or
radiator.
Additionally the module can be used to heat up water in an
external sanitary water tank and for swimming pool heating.
The module is connected to an air source outdoor unit ( here
after referred to as CDU ).
The hydronic module controls the CDU in heating or cooling
in order to achieve the desired water temperature in the
heating / cooling zones and the desired temperature of the
sanitary hot water.

System components and accessories

System without accessories

See Fig. 1, 2.
Figure Description
Fig. 1 CDU + 80AW1/80AWT hydronic module
Fig. 2 CDU + 80AW2 hydronic module
Hydronic module
9 Combined teminals ..................................................
9 Connections for AW1/AWT .....................................
9 Connections for AW2 ................................................
10 Sensor controlled terminals ...................................
Features ..............................................................................
10 Water connections ..........................................................
11 Pump speed selection ....................................................
11 Refrigerant connections ................................................
Power wiring diagram ....................................................
Wiring connection diagram ...................................
14 Commissioning ................................................................
15 Maintenance .......................................................................... 23-24
15 Filter cleaning ...................................................................
15 Adding water to the circuit ...........................................
15 Alarms and faults .............................................................
16 Glossary ...................................................................................
Safety recommendations ...................................................
16
16
17
17
The water temperature for the heating / cooling zones is
determined by the hydronic module control; the sanitary
water temperature is determined by the sanitary water tank
control.
The hydronic module is equipped with a pump to circulate
the water in the primary circuit and (with the exception
of 80AW100-, 80AWT00- and 80AW200-) with electrical
heaters.
Description
1- Outdoor unit
2- Hydronic
module
3- Heat exchanger
4- Water pump
5- Outdoor sensor
6- 3 way valve for
sanitary water
7- Buff er tank
Part number
Fig. 1
38AW050 / 38AW090 / 38AW090 /
38AW065 38AW115
80AW1 80AWT
80AW1- 80AWT - 80AW2
Page
17
17
18
18
19
20
20
20
21
22
22
23
23
24
26
26
Fig. 2
38AW115
80AW2
9