Clean The Machine - Vollrath Stoelting Manual Del Operador

OPERATION (CONTINUED)

Clean the Machine

Drain the Mix
For easier cleaning, allow the product to thaw before draining the
machine.
1. Press until the display shows MOTOR ON. This indicates
refrigeration is off.
2. Drain the product by repeatedly opening and closing the spigot.
3. Fill the tank with 1 gallon of cool tap water.
4. After 30 seconds open the spigot to drain the water out of the tank.
5. Turn off and unplug the machine.
6. Use a mild detergent and warm water to wash the steel tank bottom.
®
Stoelting Mini Soft Serve Countertop Freezer Operator's Manual
Clean and Sanitize the Components
NOTICE: Local and state health codes dictate the procedure
required. Some health codes require a four-sink process
(pre-wash, wash, rinse, sanitize, and air-dry), while other
codes require a three-sink process (without the pre-wash
step). The following procedure is a general guideline only.
Consult your local and state health codes for procedures
required in your location.
NOTICE: Do not use abrasive materials, scratching cleansers or
scouring pads. These can damage the finish.
WARNING
Electrical Shock Hazard
Do not spray water or cleaning products. Liquid could contact
the electrical components and cause a short circuit or an
electrical shock.
1. Disassemble the machine. See page 6.
2. Place the removed components in warm, 90° to 110°F (32°C to
43°C) mild detergent water and wash thoroughly.
3. Rinse the components with clean 90° to 110°F (32°C to 43°C) water.
4. Soak the following components in sanitizing solution for at least 1
minute.
5. Remove the parts. Do not remove the sanitizer. Allow the
components to air dry.
6. Dip a brush into the sanitizing solution. Wipe the tank.
Manual Night Mode (optional)
At the end of the day or between peak serving times the machine can
manually be put into Night Mode. Night Mode holds the mix in the
machine at a food safe temperature (approximately 28º F (-2.2º C)). If
you want the machine to enter and stay in Night Mode at the same
times every day, see Automatic Night Mode on page 9.
NOTICE: Night Mode does not take the place of cleaning and
sanitizing.
1. Press to select and start NIGHT MODE MAN.
2. The machine will remain in Night Mode until you manually return the
machine to SOFT MODE.
3. To exit Night Mode, press
MODE PLEASE WAIT.
until the display shows SOFT
5