Nilfisk VHS110 Z22 Manual De Instrucciones página 26

VHS110 Z22
Do not rub non-metal parts with clothes, rags, or fabrics
of any kinds (cotton, wool, synthetic, paper, etc.) that
can generate dangerous electrostatic charges.
For cleaning non metal parts, use wet clothes or rags in
order to reduce the electrostatic charges.
In any case, cleaning procedures must be performed
outside the area that has been classified as dangerous
for risk of explosion.
These machines are not suitable for vacuuming aircraft
fuel (Jet Fuel).
Standards of reference:
These machines comply with:
EN 1127-1 - EN ISO 80079-36 - EN IEC 60079-0 - EN IEC
60079-31
These machines are designed to be used in explosive
atmospheres classified as Zone 22.
Never use the machines in Zones 20, 21 and/or Zones 0, 1, 2.
They are not designed to be used for ST3 explosion class
dust, that is to say dust with value of Kst > 300 bar m/s
(ISO 6184/1 – IFA classification: http://staubex.ifa.dguv.
de/?lang=e), nor dust with an ignition energy lower than 1
mJ. For these applications, please refer to the paragraph
"Immersion Separator".
These applications are not designed to collect explosives or
chemically unstable substances.
These applications are not designed to vacuum fluids with a
low flash point (Flash Point lower than 55°C), nor for incendiary
substances (T < 200 °C).
Identification plate marking:
IT
II3D Ex tc IIIC T125°C Dc
0°C<Ta<+40°C;
GB
Check that the hose clamps are correctly tightened.
F
In case of breakage, only use original Nilfisk spare parts.
Any parts that need replacing must be replaced by trained
personnel. Never perform any kind of disassembly, tampering
D
and/or maintenance on the safety systems.
Periodically clean the motor cooling fan to prevent the motor
E
from overheating.
If all the prescriptions, precautions and maintenance
described in the previous points are not complied with, the
Nilfisk guarantee of correct operation as an ATEX machine
lapses, the validity of the ATEX Declaration of Conformity
issued by Nilfisk ceases, and the responsibility for use of
the machine lies solely with the user.
C421
CAUTION!
CAUTION!
General information for using the machine
Use the machine in accordance with the laws in force in the
country where it is used.
Besides the operating instructions and the laws in force in the
country where the device is used, the technical regulations for
ensuring safe and correct operation must also be observed
(Legislation concerning environmental and labour safety,
i.e. European Union Directive 89/391/EC and successive
Directives).
Do not perform any operation that could jeopardize the safety
of people, property and the environment.
Comply with the safety indications and prescriptions in this
instruction manual.
Proper uses
This machine is suitable for commercial use, in hotels, schools,
hospitals, factories, shops, offices and apartment hotels for
example, for hire and in any case for purposes other than
normal domestic use.
This machine is suitable for cleaning and vacuuming solid
materials in indoor and outdoor environments.
The machine has been designed to be used by one operator
at a time.
This machine consists of a vacuum unit, with an upstream filter
unit and a container for collecting the vacuumed material.
Improper Use
CAUTION!
The following use of the device is strictly forbidden:
■
Outdoors in case of atmospheric precipitation.
■
When not placed on horizontal level ground.
■ When the filter unit is not installed.
■ When the vacuum inlet and/or hose are turned to
face parts of the human body.
■ Use without the cover on the vacuum unit.
■ When the dust container is not installed.
■
Use without the guards, protective covers and
safety systems installed by the manufacturer.
■
When the cooling vents are partially or totally
clogged.
■
When the machine is covered with plastic or fabric
sheets.
■
Use with the air outlet partially or totally closed.
■ When used in narrow areas where there is no fresh
air.
■ When the cable or plug is damaged. If appliance
is not working as it should, has been dropped,
damaged, left outdoors or dropped into water,
return it to an authorized service center.
■
Vacuuming liquids with machine not equipped
with specific original stopping systems.
4