Chapter 18 Troubleshooting; Chapter 19 Warranty - Columbus KS 51 Manual De Instrucciones

Kehrsaugmaschine
KS 51|VM 45 M – KS 71|VM 60 M
CHAPTER 18 – TROUBLESHOOTING
Two main faults may occur in the KS 51/71 sweepers series: the machine causes dust during use or leaves dirt on the floor; there can be
many reasons for this but if the machine is used correctly and routine maintenance is carried out regulary, they should not occur very often.
Therefore:
THE MACHINE CAUSES DUST
THE MACHINE LEAVES TRACES OF
DIRT ON THE FLOOR
THE EXPLOSION ENGINE IS NOT
PERFORMING CORRECLTY
THE BATTERY-POWERED SWEEPER
IS NOT PERFORMING CORRECTLY;
IT IS SLOW AND IS NOT
CLEANING WELL
CHAPTER 19 - WARRANTY
This machine is guaranteed against defects in workmanship or installation for 12 months from the date of sale.
The warranty covers exclusively the replacement or repair parts that are defective. Any other request will not be accepted.
This does not include damage caused by normal wear, use different from that reported on this manual, damage caused by wrong settings,
technical operations not carried out properly, act of vandalism.
FAULTS
LEVER IN POSITION TO STOP
SUCTION
FILTERS CLOGGED
FILTER DAMAGED
FILTER BADLY INSTELLED
SIDE DUST FLAP(S) DAMAGED
CONTINUOUS USE OF THE SIDE
BROOM
THE MAIN BROOM IS NOT
CORRECTLY ADJUSTED OR IS
WORN
YOU HAVE COLLECTED WIRES,
CABLES ETC.
SIDE FLAP(S) DAMAGED
THE COLLECTION BIN IS FULL
ENGINE AIR FILTER IS DIRTY
CARBURATION WRONG
FLAT BATTERY OR NOT FULLY
CHARGED
THE RECOMMENDED BATTERY
CHARGER HAS NOT BEEN USED
CAUSES
PUSH THE KNOB TO OPEN THE
SUCTION
CLEAN THEM BY SHAKING IT WITH
THE FILTER-SHAKER AND IF
NECESSARY REMOVE AND CLEAN
IT THOROUGHTLY
REPLACE IT
MAKE SURE IS CORRECTLY
INSERTED
REPLACE IT (THEM)
USE THE SIDE BROOM ONLY FOR
THE EDGES, BORDERS AND
CORNERS
CHECK THE MAIN BROOM AND IT
"TRACK"
REMOVE THEM
REPLACE IT (THEM)
EMPTY IT
CLEAN OR REPLACE IT
RECARBURATE
CHECK THE LEVER OF THE
ELECTROLYTE AND CARRY OUT A
NEW COMPLETE BATTERY
CHARGING CYCLE
USE AN APPROPRIATE BATTERY
CHARGER
27
REMEDIES