Installation; Features And Controls; Before First Use - Vollrath VCBA118 Manual Para Operadores

INSTALLATION

NOTICE: Do not lay the machine on its side or back.
NOTICE: Do not lift the machine by the tank, auger, or handles. Only
lift by grasping the bottom of the machine.
NOTICE: The machine must sit in the upright position for 24 hours
before turning it on. This will allow the oil in the
compressor to settle into place following shipping.
1. Remove the machine from the packaging, which you should keep in
case it is needed in the future.
2. Check that the machine has not been damaged during transport. If it
has, make a report to the carrier immediately.
3. Position the machine on a countertop capable of supporting the
weight, even at full load.

FEATURES AND CONTROLS

The machine is equipped with a power switch and a light switch. In
addition, each bowl is individually operated by a Cold Drink/Granita
switch. It is possible to dispense both cold drinks and Granita from one
machine.
When a bowl is in Cold Drink mode the beverage temperature is
controlled by the corresponding temperature control knob.
When a bowl is in Granita mode the mix consistency is controlled by
the corresponding adjustment screw. See "Adjustments" on page 4.
C
B
A
A Control Panel
B Condensation Ring
C Spigot Assembly
D Lights
E Auger
F Evaporator Cylinder
G Outer Magnetic Rotor Assembly
2

BEFORE FIRST USE

Before use, the machine must be disassembled, cleaned and sanitized.
1. Disassemble the machine. See page 5
2. Clean and sanitize the components. See page 4.
3. Re-assemble and lubricate the components. See page 6.
4. Sanitize the machine. See page 3.
K I
D
H Master Power Switch
0 position
E
I position
F
G
I Bowl Cold Drink / Granita Switch
I position
0 position
II position
J Light Switch
I position
0 position
K Temperature Control Knob
Turn clockwise to decrease temperature.
Turn counterclockwise to increase temperature.
Frozen Beverage Granita Machines Operator's Manual
J I
K
Power is turned OFF to all functions.
Power is turned ON to all functions and the
other switches are enabled. The fan motor
runs.
Cold Drink Mode. Auger and refrigeration ON.
Auger and refrigeration OFF.
Granita Mode. Auger and refrigeration ON.
ON
OFF
H