Vanguard 10V000 Manual Del Operario página 13

specified by the manufacturer's instructions. This keeps fuel fresh and decreases fuel-
related problems or contamination in the fuel system.
It is not necessary to drain fuel from the engine when STA-BIL
®
360° PROTECTION™ is added as instructed. Before storage, turn the engine ON for 2
minutes to move the fuel and stabilizer through the fuel system.
If gasoline in the engine has not been treated with a fuel stabilizer, it must be drained
into an approved container. Run the engine until it stops from lack of fuel. The use of a
fuel stabilizer in the storage container is recommended to maintain freshness.
Engine Oil
While the engine is still warm, change the engine oil. See the Change Engine Oil
section.
Troubleshooting
For assistance, contact your local dealer or go to VanguardPower.com or call
1-800-999-9333 (in USA).
Specifications
Model: 10V000
Displacement
Bore
Stroke
Oil Capacity
6:1 Gear Reduction - Oil Type (Figure 21)
6:1 Gear Reduction - Oil Capacity (Figure 21)
2:1 Wet Clutch Reduction - Oil Type (Figure 23)
2:1 Wet Clutch Reduction - Oil Capacity (Figure 23)
Spark Plug Gap
Spark Plug Torque
Armature Air Gap
Intake Valve Clearance
Exhaust Valve Clearance
Model: 12V000
Displacement
Bore
Stroke
Oil Capacity
6:1 Gear Reduction - Oil Type (Figure 21)
6:1 Gear Reduction - Oil Capacity (Figure 21)
2:1 Wet Clutch Reduction - Oil Type (Figure 23)
2:1 Wet Clutch Reduction - Oil Capacity (Figure 23)
Spark Plug Gap
Spark Plug Torque
Armature Air Gap
Intake Valve Clearance
Exhaust Valve Clearance
Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and
1% for each 10° F (5.6° C) above 77° F (25° C). The engine will operate satisfactorily
at an angle up to 30°. Refer to the equipment operator's manual for safe allowable
operating limits on slopes.
Service Parts - Model: 10V000, 12V000
Service Part
Paper Air Filter, Model 10V000 (Figure 24)
Paper Air Filter, Model 12V000 (Figure 24)
Paper Air Filter, Low-Profile, Model 10V000 (Figure 25)
Paper Air Filter, Low-Profile, Model 12V000 (Figure 25)
Resistor Spark Plug
Spark Plug Wrench
Spark Tester
We recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
Power Ratings: The gross power rating for individual gasoline engine models is
labeled in accordance with SAE (Society of Automotive Engineers) code J1940 Small
Engine Power & Torque Rating Procedure, and is rated in accordance with SAE J1995.
Torque values are derived at 2600 RPM for those engines with "rpm" called out on the
label and 3060 RPM for all others; horsepower values are derived at 3600 RPM. The
gross power curves can be viewed at www.BRIGGSandSTRATTON.COM. Net power
values are taken with exhaust and air cleaner installed whereas gross power values
are collected without these attachments. Actual gross engine power will be higher than
net engine power and is affected by, among other things, ambient operating conditions
and engine-to-engine variability. Given the wide array of products on which engines
are placed, the gasoline engine may not develop the rated gross power when used in a
given piece of power equipment. This difference is due to a variety of factors including,
but not limited to, the variety of engine components (air cleaner, exhaust, charging,
cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions
(temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing
and capacity limitations, Briggs & Stratton may substitute an engine of higher rated
power for this engine.
Warranty
10.313 ci (169 cc)
2.44 in (62 mm)
2.204 in (56 mm)
Briggs & Stratton Engine Warranty
18 - 20 oz (,54 - ,59 L)
Effective January 2019
80W-90
Limited Warranty
4 oz (,12 L)
Briggs & Stratton warrants that, during the warranty period specified below, it will repair
10W30
or replace, free of charge, any part that is defective in material or workmanship or
10 oz (,30 L)
both. Transportation charges on product submitted for repair or replacement under this
warranty must be borne by purchaser. This warranty is effective for and is subject to
.030 in (,76 mm)
the time periods and conditions stated below. For warranty service, find the nearest
180 lb-in (20 Nm)
Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM.
The purchaser must contact the Authorized Service Dealer, and then make the product
.010 - .013 in (,25 - ,35 mm)
available to the Authorized Service Dealer for inspection and testing.
.004 - .006 in (,10 - ,15 mm)
There is no other express warranty. Implied warranties, including those of
.005 - .007 in (,15 - ,20 mm)
merchantability and fitness for a particular purpose, are limited to the warranty
period listed below, or to the extent permitted by law. Liability for incidental or
consequential damages are excluded to the extent exclusion is permitted by law. Some
states or countries do not allow limitations on how long an implied warranty lasts,
12.387 ci (203 cc) and some states or countries do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation and exclusion may not apply to you.
2.677 in (68 mm)
This warranty gives you specific legal rights and you may also have other rights which
2.204 in (56 mm)
vary from state to state and country to country
18 - 20 oz (,54 - ,59 L)
80W-90
Vanguard®; Commercial Series
4 oz (,12 L)
Consumer Use - 36 months
10W30
Commercial Use - 36 months
10 oz (,30 L)
XR Series
.030 in (,76 mm)
Consumer Use - 24 months
180 lb-in (20 Nm)
Commercial Use - 24 months
.010 - .013 in (,25 - ,35 mm)
All Other Engines Featuring Dura-Bore™ Cast Iron Sleeve
.004 - .006 in (,10 - ,15 mm)
Consumer Use - 24 months
.005 - .007 in (,15 - ,20 mm)
Commercial Use - 12 months
All Other Engines
Consumer Use - 24 months
Commercial Use - 3 months
Part Number
84002309
596760
596760
596760
597383
Service Parts - Model: 10V000, 12V000
Standard Warranty Terms
3
1
These are our standard warranty terms, but occasionally there may
be additional warranty coverage that was not determined at time of
publication. For a listing of current warranty terms for your engine, go to
BRIGGSandSTRATTON.com or contact your Briggs & Stratton Authorized Service
Dealer.
2
There is no warranty for engines on equipment used for prime power in place
of a utility; standby generators used for commercial purposes, utility vehicles
exceeding 25 MPH, or engines used in competitive racing or on commercial or
rental tracks.
19576, 5402
19368
4
.
1, 2, 3
13