Maintenance; Maintenance Prompts; Maintenance Chart; Maintenance Procedures - Ingersoll Rand TS1A-13A Manual De Manejo Y Mantenimiento

11.1 MAINTENANCE PROMPTS

The maintenance prompt is a service warning that occurs when the unit
has been operated a certain number of hours, based on energized time.
These warnings are set prior to the dryer being shipped. They can not
be disabled.

11.2 MAINTENANCE CHART

The MAINTENANCE CHART indicates the various components and the intervals when the maintenance has to take place. Note that any Local or
National codes that require specific maintenance that exceeds the requirements of this section must be adhered to.
Hours:
Panel Filter Element
Condenser
Drain Valve Strainer
High Refrigerant Temperature Switch
High Pressure Switch
High Side Pressure
(1)
Low Side Pressure
Fan Pressure Switch
High Superheat Switch
Oil Level
Condensate Drain System
(1)
The low side refrigerant pressure may need to be adjusted more often if local ambient conditions change frequently.

11.3 MAINTENANCE PROCEDURES

CAUTION
Before beginning any work on the dryer, read and understand the
safety instructions earlier on in this manual. Open, lock and tag
the main electrical disconnect and isolate the dryer from the air
system. Do not under any circumstances open any drain valve or
remove components from the dryer until this has been carried
out. Ensure that all pressure has been vented from the dryer.
CAUTION
When using any form of liquid for cleaning, ensure that all
electrical components are protected or covered to prevent
ingress of liquid.
All manuals and user guides at all-guides.com

11.0 MAINTENANCE

TS Maintenance Schedule
4300
Replace
Check / clean
Check / clean
Check
Check
Check
Check/Adjust
Check
Check
Check
Check
TS1A–13A
http://air.irco.com
Preventative Maintenance Warning
This warning occurs when the preventative maintenance interval has
been reached. The warning can only be cleared once the preventative
maintenance work is completed by an authorized Ingersoll Rand
technician.
8600 12900
Replace Replace
Check / clean Check / clean
Check / clean Check / clean
Check Check
Check Check
Check Check
Check/Adjust Check/Adjust
Check Check
Check Check
Check Check
Check Check
WARNING
The dryer's refrigeration system operates in a pressurised
shutdown mode. If the compressor stops, the system will contain
high pressure refrigerant. The refrigeration system must only be
opened by a qualified technician certified in handling refrigerants.
WARNING
Use suitable equipment for lifting heavy items and ensure loose
components are adequately supported to eliminate risk of
dropping.
Every 4300
thereafter
Replace
Check / clean
Check / clean
Check
Check
Check
Check/Adjust
Check
Check
Check
Check
43