Publicidad
Idiomas disponibles
Idiomas disponibles
Moving parts, unexpected engine start-
up and compressed air can cause serious
injury. Always disconnect the spark plug
wire and relieve pressure from the air
tank before performing any of these ser-
vice procedures. Never operate the air
compressor with the belt guard removed.
A clean air compressor runs cooler and provides longer
service. Clean or blow off fins and any other parts of the
air compressor that collect dust or dirt. Do not place rags,
containers or other material on or against the ventilation
openings in the belt guard. Adequate ventilation is nec-
essary to maintain proper air compressor operating tem-
perature.
For any maintenance instructions, recom-
mended oil and fuel for the gasoline en-
gine, refer to "Gasoline Engine Owners
Manual".
ROUTINE MAINTENANCE SCHEDULE
DAILY
1. Check the gasoline engine and air compressor
pump oil levels; add if necessary.
NOTE
Drain and refill the compressor pump
crankcase after the first 100 hours of op-
eration.
2. Drain water from the air tank and any
moisture separators or transformers.
3. Check for any unusual noise and/or vibration.
4. Manually check all safety valves to make sure
they are operating properly.
MAINTENANCE
5. Check the gasoline engine's fuel level. Add fuel
if necessary.
6. Inspect for oil leaks and repair any leaks found.
WEEKLY
1. Clean and inspect the compressor air
intake filter; replace if necessary.
2. Check the condition of the air cleaner on the
gasoline engine. Clean and/or replace as
necessary.
3. Inspect condition of drive belt; replace if
necessary.
4. Clean outside parts of the compressor as well as
the engine in order to maintain efficient cooling.
MONTHLY
1. Check the alignment of the engine pulley to the
flywheel if necessary, align to within 1/16 inch.
2. Inspect for and correct any oil leaks.
3. Check drive belt tension adjust if necessary.
4. Inspect air lines and fittings for leaks; correct as
necessary.
EVERY 500 HOURS OF OPERATION
1. Drain and refill compressor crankcase with clean
oil.
EVERY 2000 HOURS OF OPERATION, OR IF
A PROBLEM IS SUSPECTED
1. Check condition of compressor pump intake
and exhaust valves. Replace if damaged or
worn out.
PAGE 12
Publicidad
