Tabla de contenido
Publicidad
Manual del operario
Seguridad general
Lado del distribuidor / extremo de la plataforma TZ-50
82505
82505
Crushing Hazard.
Contact with moving
parts will cause death
or serious injury.
Keep clear of elevated
components.
82505 A
82558
WARNING
Injection Hazard
Escaping fluid under pressure can
penetrate skin, causing serious injury.
Relieve pressure before disconnecting
hydraulic lines. Keep away from leaks
and pin holes. Use a piece of cardboard
or paper to search for leaks. Do not use
hand.
Fluid injected into skin must be
surgically removed within a few hours
by a doctor familiar with this type of
injury or gangrene will result.
82558 B
6
STOP
97551
CAUTION
Compartment access is restricted.
Improper contact
Only trained maintenance personnel
should access compartments. Access
with components
by operator is only advised when
under any cover
performing Pre-operation Inspection.All
will cause serious
compartments must remain closed and
injury.
secured during operation.
97551 A
43617
DANGER
DANGER
DANGER
DANGER
DANGER
Tip-over hazard.
Failure to replace batteries with
proper weight batteries will cause
death or serious injury.
Batteries are used as counterweight
and are critical to machine stability.
Each battery must weigh
65 pounds (29.5 kg).
43617 017A
Genie TZ-50
Tercera edición • Tercera impresión
82479
97551
1263140
82479
DANGER
46262
Failure to read, understand and
obey the operator's manual
and safety rules will result in
Failure to obey the following battery and charger safety rules
death or serious injury.
will cause death or serious injury.
The operator is responsible for safe machine
operation.This includes:
1 Avoid hazardous situations.
2 Always perform a pre-operation inspection.
3 Always perform function tests prior to use.
4 Inspect the work place.
5 Only use the machine as it was intended.
Do not operate unless:
You read, understand and obey:
- manufacturer's instructions and safety rules -
safety and operator's manuals and decals
- employer's safety rules
- applicable governmental regulations
You are properly trained to safely operate this
machine.
82479 B
1263140
DANGER
Electrocution Hazard
Death or injury can result from contacting electric
power lines.
Always contact the electric power line owner. The
electric power shall be disconnected or the power lines
moved or insulated before machine operations begin.
1263140 A
43617
46262
82558
Burn Hazards
Explosion Hazards
· Batteries contain acid.
· Keep sparks, flames and
Always wear protective
lighted tobacco away from
clothing and eyewear
batteries. Batteries emit
when working with
explosive gas.
batteries.
· Battery tray should be open
· Avoid spilling or
during entire charging cycle.
contact with battery
· Do not contact battery
acid. Neutralize battery
terminals or cable clamps
acid spills with baking
with tools that may cause
soda and water.
sparks.
· Avoid contact with hot
Lifting Hazard
or live electric circuits.
· Use proper lifting techniques
· Do not expose
and appropriate number of
batteries or charger to
people when lifting batteries.
water and/or rain.
46262 C
Maintain required clearance.
Line Voltage Required Clearance
0 to 300V Avoid Contact
300V to 50KV 10 ft 3.05 m
50KV to 200KV 15 ft 4.60 m
200KV to 350KV 20 ft 6.10 m
350KV to 500KV 25 ft 7.62 m
500KV to 750KV 35 ft 10.67 m
750KV to 1000KV 45 ft 13.72 m
over 1000 KV
see operator manual
N.º de pieza 133555SP
Electrocution
Hazards
· Connect charger to a
grounded AC 3-wire
electrical outlet only.
· Before each use, inspect
for damaged cord, cables
and wires. Replace
damaged items before
operating.
Component Damage
Hazard
· Do not use any charger
greater than 24V to charge
batteries.
Publicidad
Tabla de contenido
