Frequently Asked Questions/ Troubleshooting - Vito Agro VIMEDTD12A Manual De Instrucciones

FREQUENTLY ASKED QUESTIONS/ TROUBLESHOOTING

Question/Problem - Cause
Cause
The combustion engine does not start:
• There is no fuel in the tank;
The fuel line is clogged;
The fuel valve is closed;
• The fuel in the tank is of poor quality, has water, is
dirty or is already old
• The air filter is dirty;
• The battery is discharged;
• Poor wiring;
Start-up difficulties or reduced combustion engine
power:
• There is water in the fuel tank;
• The fuel tank is dirty;
• The air filter is dirty;
The engine runs irregularly:
• The air filter is dirty;
The combustion engine overheats:
• Cooling fins are dirty;
• Low level of engine oil;
• The combustion engine's housing is covered by
dirt;
The tiller is smoking:
• Too high level of engine oil;
• The air filter is dirty;
Strong vibrations while operating:
• Loose engine housing;
Low performance;
• The tines are installed incorrectly;
• The tines are worn out;
• Depth gauge is incorrectly set;
The tines do not rotate:
• Tines are not coupled to the drive shaft;
Loud noise in the gearbox:
• The gearbox oil level is too low;
Solution
• Fill the tank;
Clean the fuel line and open the fuel valve;
Open the fuel valve;
• Use new fuel (diesel)
• Clean/replace the air filter;
• Charge the battery;
• Recheck battery terminals connection and ignition
system;
• Empty the fuel tank;
Clean the fuel line;
• Clean the fuel tank;
• Clean/replace the air filter;
• Clean/replace the air filter;
• Clean the cooling fins;
• Top up the engine oil level;
• Remove dirt from the combustion engine;
• Check/Adjust oil level;
• Clean/replace the air filter;
• Tighten the engine fixing bolts;
• Install the tines incorrectly;
• Replace the tines;
• Adjust the depth gauge;
• Fix them;
• Check gearbox oil level and adjust if necessary;
49