Tabla De Contenido; Limited Warranty - Grundfos UPS 200 Serie Instrucciones De Instalación Y Funcionamiento

English (US) Installation and operating instructions
Original installation and operating
instructions
CONTENTS
1. Limited warranty
2. Introduction
2.1 Safety warning
3. Pre-installation checklist
3.1 Confirm you have the correct pump
3.2 Check the condition of the pump
3.3 Verify electrical requirements
3.4 Location
3.5 Pumped liquid requirements
4. Installation procedures
4.1 Electrical preparation
4.2 Piping considerations
4.3 Connect the pump
4.4 Electrical connection
5. Starting the pump
5.1 Vent the piping system
5.2 Check the direction of shaft rotation
5.3 Speed selection
6. Troubleshooting
6.1 Fault finding chart
6.2 Preliminary checks
6.3 Current measurement
6.4 Insulation resistance (lead-to-ground) 15
6.5 Winding resistance (line-to-line)
6.6 Winding resistance chart
7. Replacing components
7.1 Removing the pump head
7.2 Fitting the pump head
7.3 Replacing the terminal box or
capacitor
8. Disposal
WARNING
Prior to installation, read these
installation and operating instructions.
Installation and operation must
comply with local regulations and
accepted codes of good practice.
This booklet should be left with the
owner of the pump for future
reference and information regarding
its operation.
4

1. Limited warranty

Products manufactured by GRUNDFOS PUMPS
CORPORATION (Grundfos) are warranted to
the original user only to be free of defects in
Page material and workmanship for a period of
18 months from date of installation, but not more
4
than 24 months from date of manufacture.
5
Grundfos' liability under this warranty shall be
limited to repairing or replacing at
5
Grundfos' option, without charge, F.O.B.
5
Grundfos' factory or authorized service station,
5
any product of Grundfos' manufacture.
5
Grundfos will not be liable for any costs of
5
removal, installation, transportation, or any other
charges which may arise in connection with a
5
warranty claim. Products which are sold but not
6
manufactured by Grundfos are subject to the
7
warranty provided by the manufacturer of said
7
products and not by Grundfos' warranty.
7
Grundfos will not be liable for damage or wear to
products caused by abnormal operating
8
conditions, accident, abuse, misuse,
8
unauthorized alteration or repair, or if the
10
product was not installed in accordance with
10
Grundfos' printed installation and operating
10
instructions.
11
To obtain service under this warranty, the
defective product must be returned to the
13
distributor or dealer of Grundfos' products from
13
which it was purchased together with proof of
14
purchase and installation date, failure date, and
15
supporting installation data. Unless otherwise
provided, the distributor or dealer will contact
15
Grundfos or an authorized service station for
instructions.
17
Any defective product to be returned to
19
Grundfos or a service station must be sent
19
freight prepaid; documentation supporting the
19
warranty claim and/or a Return Material
Authorization must be included if so instructed.
20
GRUNDFOS WILL NOT BE LIABLE FOR ANY
20
INCIDENTAL OR CONSEQUENTIAL
DAMAGES, LOSSES, OR EXPENSES ARISING
FROM INSTALLATION, USE, OR ANY OTHER
CAUSES. THERE ARE NO EXPRESS OR
IMPLIED WARRANTIES, INCLUDING
MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, WHICH EXTEND
BEYOND THOSE WARRANTIES DESCRIBED
OR REFERRED TO ABOVE.
Some jurisdictions do not allow the exclusion or
limitation of incidental or consequential
damages and some jurisdictions do not allow
limit actions on how long implied warranties may
last. Therefore, the above limitations or
exclusions may not apply to you. This warranty
gives you specific legal rights and you may also
have other rights which vary from jurisdiction to
jurisdiction.