Tabla De Contenido - Generac 0060550 Manual De Instrucciones

Section 1: Safety Rules & General
Information
Introduction ..........................................................1
Read This Manual Thoroughly ................................1
How to Obtain Service .............................................1
Safety Rules .........................................................1
General Hazards .....................................................2
Exhaust Hazards .....................................................2
Electrical Hazards ....................................................3
Fire Hazards ............................................................3
Explosion Hazards ...................................................4
General Rules .......................................................4
Before You Begin ....................................................4
NEC Requirements ..................................................5
Standards Index ......................................................5
Section 2: Unpacking and Inspection
General .................................................................7
Required Tools .....................................................7
Unpacking ............................................................7
Parts Shipped Loose ...........................................9
Section 3: Site Selection and Preparation
Site Selection .....................................................11
Installation Guidelines for Stationary Air-Cooled
Generators .............................................................12
Annex A - Explanatory Material ...........................12
Site Preparation .................................................13
Material Sufficient for Level Installation .................13
Transportation Recommendations ........................13
Section 4: Generator Placement
Generator Placement .........................................15
Fascia Installation (If Applicable) .....................15
Section 5: Fuel Conversion/Gas
Connections
Fuel Requirements and Recommendations ....17
Fuel Conversion .................................................17
Fuel Consumption .............................................18
Fuel Line Sizing .................................................18
Natural Gas Pipe Sizing ........................................18
LP Vapor Pipe Sizing .............................................19
Installation Guidelines For 60 Hz Air-cooled Generators
Table of Contents
Installing and Connecting Gas Lines .............. 19
Checking Gas Line Connections ..................... 20
Natural Gas Vapor Installation (typical) .......... 21
LP Vapor Installation (typical) .......................... 22
Section 6: Electrical Connections
Generator Connections .................................... 23
Control Wiring ................................................... 23
Main AC Wiring .................................................. 24
Load Shed Functionality ................................... 24
Automatic Voltage Regulator (AVR) Cooling
Fans .................................................................... 24
Battery Requirements ....................................... 25
Battery Installation ............................................ 25
Section 7: Control Panel/Start-up/Testing
Control Panel Interface ..................................... 27
Generator Set-up ............................................... 27
Before Initial Start-up ........................................ 28
Check Manual Transfer Switch Operation ...... 29
Electrical Checks ............................................... 30
Generator Tests Under Load ............................ 30
Checking Automatic Operation ........................ 31
Installation Summary ........................................ 31
Shutting Generator Down While Under Load .... 31
Shutoff Valve .........................................................19
Flexible Fuel Line ..................................................19
Sediment Trap .......................................................20
Using the AUTO/MANUAL/OFF Buttons ..............27
Activation ...............................................................27
Cold Smart Start ....................................................28
Setting The Exercise Timer ...................................28
Installation Wizard .................................................28
Interconnect System Self Test Feature .................28
Before starting, complete the following: ................29
Table of Contents
iii