23 9.1 Temporary Shutdown; 23 9.2 Change Of Location; 23 9.3 Disposal And Scrapping; 23 9.3.1 Substances Hazardous To Water - Bosch VLH 2155 Manual Original

Monthly:
Component Action
Exposed surfaces and Cleaning:
edges Clean all contaminated surfaces and
apply preservative agent if applicable.
Exposed surfaces and Paintwork care:
edges Sand down paintwork blemishes with
sand paper (grain size 120) and touch
up with the appropriate RAL shade.
Synchronizing cables Visual inspection:
and pulleys Components must not be damaged or
worn.
Typical examples of cable damage: In-
dividual wire breaks, kinking, constric-
tion, flattening, looping, tangling.
Pay particular attention to cables in
the area of the threaded end pieces.
Limit switch Functional test:
Raise the switch rod.
Every 3 months:
Component Action
Support arms Lubricate the shafts (lithium grease).
Mounts Lubricate the spindles (lithium
grease). Make sure the mounts cannot
be completely screwed out.
Every 6 months:
Component Action
Hydraulic unit Check fluid level in tank:
Dipstick must be immersed in fluid
(max. 5 mm) when lifting platform is
fully lowered.
Top up with specified hydraulic fluid if
necessary.
Sliders at lifting car- Lubricate the inner surfaces of the lift-
riage ing columns (multi-purpose grease).
Shear connector Check tightening torque.
Re-tighten to specified torque if nec-
essary.
Robert Bosch GmbH
Decommissioning | VLH 2155 | 33
9. Decommissioning
9.1 Temporary shutdown
In the event of lengthy periods of non-use:
¶
Disconnect the VLH 2155 from the mains.
¶
Lock the master switch.
9.2 Change of location
¶
If the VLH 2155 is passed on, all the documentation
included in the scope of delivery must be handed over
together with the unit.
¶
The VLH 2155 is only ever to be transported in the
original or equivalent packaging.
¶
Unplug the electrical connection.
¶
Heed the notes on initial commissioning.
9.3 Disposal and scrapping
9.3.1 Substances hazardous to water
!
Oils and greases as well as refuse containing oil and
grease (e.g. filters) represent a hazard to water.
1. Substances hazardous to water must not be allowed
to enter the sewage system.
2. Substances hazardous to water must be disposed of
in accordance with the applicable regulations.
9.3.2 VLH 2155 and accessories
1. Disconnect the VLH 2155 from the mains and detach
the power cord.
2. Dismantle the VLH 2155 and sort out and dispose
of the different materials in accordance with the ap-
plicable regulations.
VLH 2155, accessories and packaging should
be sorted for environmental-friendly recycling.
¶
Do not dispose VLH 2155 into household
waste.
Only for EC countries:
The VLH 2155 is subject to the European
directive 2012/19/EC (WEEE).
Dispose of used electrical and electronic de-
vices, including cables, accessories and batte-
ries, separately from household waste.
¶
Make use of the local return and collection
systems for disposal.
¶
Proper disposal of prevents environmental
pollution and possible health hazards.
en
|
1 689 989 141 2017-05-08