Service Kits; Contaminated Pumps - Grundfos SL1 Instrucciones De Instalación Y Funcionamiento

10.5 Service kits

The following service kits are available for all SL1, SLV pumps and can be ordered as required
10.5.1 Impeller fitting kit
Pos. Description
9a Key
66 Washer
157 Corrugated spring
188a Screw
10.5.2 Wear ring kit (SL1)
Pos. Description
46 Seal ring
49c Wear ring
10.5.3 Shaft seal kit
Pos. Description
105 Shaft seal cartridge
107 O-ring
153b O-ring
157 Corrugated spring
For position numbers, see pages 94 and 95.
Warning
The cable must only be replaced by Grundfos or
a service workshop authorized by Grundfos.
For service parts not shown in the above table, consult
www.grundfos.com WebCAPS, Service.
Examples of service parts:
• cable
• pump housing
• impeller
• bearings
• shaft/rotor
• clamp
• stator
• motor complete, both standard and FM.
26
2-pole:
4-pole:
Kit no:
Free passage:
Rubber type:
Kit no:
2-pole:
4-pole:
Rubber type:
Kit no:
4.3 x 0.12 inch (110 x 3 mm)
5.3 x 0.12 inch (134.5 x 3 mm)
6.3 x 0.12 inch (160 x 3 mm)
0.67 x 0.09 inch (17.0 x 2.4 mm)
1.1 x 0.08 inch (28 x 2 mm)
3.0 - 5.5 hp (2.2 - 4.0 kW)
1.5 - 3.0 hp (1.1 - 2.2 kW)
96102365
1
1
1
1
2" ( ∅ 50) 3" ( ∅ 80)
NBR NBR
96102362 96102363
1 1
1 1
3.0 - 5.5 hp (2.2 - 4.0 kW)
1.5 - 3.0 hp (1.1 - 2.2 kW)
NBR
96102360
1
1
1
1
1

10.6 Contaminated pumps

If a pump has been used for a liquid which is
injurious to health or toxic, the pump will be
Note
classified as contaminated.
If Grundfos is requested to service the pump, Grundfos must be
contacted with details about the pumped liquid, etc. before the
pump is returned for service. Otherwise Grundfos can refuse to
accept the pump for service.
Possible costs of returning the pump are to be paid by the
customer.
However, any application for service (no matter to whom it may
be made) must include details about the pumped liquid if the
pump has been used for liquids which are injurious to health or
toxic.
Before a pump is returned, it must be cleaned in the best possible
way before it is returned.
Service instruction and service video can be found on
www.grundfos.com.
8.0 - 15.0 hp (6.0 - 11 kW)
4.0 - 10.0 hp (3.0 - 7.5 kW)
96102366
1
1
1
1
4" ( ∅ 100)
NBR
96102364
1
1
8.0 - 15.0 hp (6.0 - 11 kW)
4.0 - 10.0 hp (3.0 - 7.5 kW)
NBR
96102361
1
1
1
1
1