Transport, Installation, Initial Operation And Taking Out Of Service; Transport; Assembly - Hupfer SGR Manual Del Usuario

Section 4
Page 20
4 Transport, Installation, Initial Operation and Taking out of
Service
4.1

Transport

The delivered conveyor system with a length of up to 6 m is completely assembled, wired and set so that it is
ready for operation.
Conveyor systems with a length of more than 6 m will be delivered segments that have to be assembled.
When loading, use only hoists and load lifting devices approved for appliances 1.5 times heavier than the
conveyor system to be lifted. Only transport vehicles that are approved for the weight of the appliance may
be used.
The scope of delivery is specified in the shipping documents in accordance with the valid purchase
agreement and included with the delivery item.
4.2

Assembly

DANGER
DANGER
CAUTION
CAUTION
INFO
Belt Conveyor System
SGR | SPV

Transport, Installation, Initial Operation and Taking out of Service

Hazardous electrical voltage
Electrical current can pose a considerable threat to life and physical well-
being and may lead to injuries.
Only an electrician or instructed staff under the guidance and supervision of
an electrician may work on electrical systems or operational equipment; they
must comply with the electrical industry rules while doing so.
Defective emergency stop
In case of fault, e.g. from defective fuses, the drives may continue to run even
after the emergency stop has been pressed.
Rotating machine parts
There is an indirect risk of injuries of the fingers caused by being pulled into
the appliance and crushing.
Avoid any direct contact with the running conveyor belt and the outlet, feeding
and deflection points during assembly or when performing any other work.
Never reach into the hazardous area of the conveyor system. Before
switching on the conveyor system, make sure there is no risk of reactivation of
the belt.
Injury to persons
The segments and the conveyor belt may only be assembled by two persons.
Wear protective goggles and safety gloves at all times when placing and
joining the belt.
Conveyor systems longer than 6 m
The following section only applies to conveyor systems longer than 6 m which
need not be delivered and mounted as a unit.
Transport
4330053_A7