Cooling System - Kawasaki VERSYS 1000 Manual De Servicio

Periodic Maintenance Procedures

Cooling System

Coolant Level Inspection
○
Check the level when the engine is cold (room or ambi- ent temperature).
•
Check the coolant level in the reserve tank [A] with the motorcycle held
perpendicular (Do not use the side
stand).
If the coolant level is lower than the "L" level line [B], re- move the right fuel
tank cover (see Fuel Tank Cover Re- moval in the Frame chapter), and then
unscrew the re- serve tank cap and add coolant to the "F" level line [C]. "L":
Low
"F": Full
For refilling, add the specified mixture of coolant and soft water
coolant and degrades its anticorrosion properties. The diluted coolant
can attack the aluminum en- gine parts. In an emergency, soft water
alone can be added. But the diluted coolant must be returned to the
correct mixture ratio within a few days.
If coolant must be added often or the reservoir tank has run
completely dry, there is probably leakage in the cooling system.
Check the system for leaks. Coolant ruins painted surfaces.
Immediately wash away any coolant that spills on the frame, engine,
wheels or other painted parts.
Cooling System Inspection
Water Hose and Pipe Inspection (coolant leak, damage,
○
i nstallation condition)
The high pressure inside the water hose can cause
coolant to leak [A] or the hose to burst if the line is not
properly maintained.
•
Visually inspect the hoses for signs of deterioration.
Squeeze the hoses A hose should not be hard and brittle, nor should it be soft
or swollen.
Replace the hose if any fraying, cracks [B] or bulges [C]
are noticed.
•
Check that the hoses are securely connected and clamps
are installed correctly.
Torque - Water Hose Clamp Screws: 3.0 N·m (0.31 kgf·m,
27 in·lb)
Coolant Change
Coolant can be extremely hot and cause severe burns, is toxic and
very slippery. Do not remove the radiator cap or attempt to change the
coolant when the engine is hot; allow it cool completely. Immediately
wipe any spilled coolant from tires, frame, engine or other painted
parts. Do not ingest coolant.
NOTE
NOTICE
Adding water alone dilutes the
WARNING
PERIODIC MAINTENANCE 2-25