Hydraulic Oil; Hydraulic Hoses - Jungheinrich EKS 314 Manual De Instrucciones

6.5

Hydraulic oil

– Prepare the truck for maintenance and repairs
IMPORTANT Oil must never be allowed to enter the drainage system or the soil. Used oil
must be preserved until it can be disposed of in the correct manner.
IMPORTANT Only fill or drain hydraulic oil when the mast is completely lowered.
Remove the electronic compartment cover at the back.
Draining oil:
Suction off the hydraulic oil with the dis-
charge filter removed (4). If this is not
possible, the hydraulic oil can be drained
from the bottom of the hydraulic reser-
voir after the oil drain screw (6a) has
been unscrewed.
Adding oil:
Screw in the oil drain screw (6a). Re-
plenish with new hydraulic oil up to the
Max. mark on the dipstick (7). Screw the
discharge filter backon.
QwD
Note carefully which hydraulic fluid should be used. If
"Plantohyd 22 S" biodegradable hydraulic fluid is to be
used, the hydraulic tank will have the warning label:
"Only use biodegradable hydraulic fluid" (6b). In this
case, only "Plantohyd 22 S" biodegradable hydraulic
fluid may be used to fill the hydraulic tank.
QwD
An oil change from "Plantohyd 22 S" biodegradable hydraulic fluid to "HLP
D22" hydraulic fluid is not permitted. The same applies to an oil change
from"HLP D22" hydraulic fluid to "Plantohyd 22 S" biodegradable hydraulic
fluid.
Furthermore, operation with a mixture of "HLP D22" hydraulic fluid and
"Plantohyd 22 S" biodegradable hydraulic fluid is not permitted.
Checking the hydraulic oil level
When the mast is fully lowered, check that the hydraulic oil level is between the min.
and max. markings on the dipstick (7).
If this is not the case, add new hydraulic oil.
6.6

Hydraulic hoses

Hose lines must be replaced every six years, see Safety Regulations for Hydraulic
Hose Lines ZH 1/74.
G 14
7
4
6a
6b