Tabla de contenido
Publicidad
ENGINE COMPONENTS
Fig. 1
1
Engine ID. Label: Model, Type & Code Numbers
Note:
See ENGINE IDENTIFICATION NUMBERS -
last section
2
Spark Plugs (3x)
3
Thermostat
4
Oil Filler Cap
5
Ignition Coils (3x)
6
Electric Starter
7
Oil Pan
8
Alternator
9
Coolant Temperature Switch
10
Governor Lever
11
Oil Drain Plugs (2x)
12
Oil Filter
13
Dipstick
14
Oil Pressure Switch
15
Carburetor
ADDITIONAL COMPONENTS
Air Cleaner Assembly
Fig. 2
1
Body
2
Cartridge
3
Cover
4
Clamps
Gasoline Filter Assembly
Fig. 3
PANEL COMPONENTS
Typical Controls (if equipped)
Fig. 4
1 Throttle Control
2 Gasoline Shut Off Valve
3 Choke Control
4 Starter Switch
Typical Gauges (if equipped)
Fig. 5
1 Gasoline Gauge
2 Coolant Temperature Gauge
3 Hour Meter
- Indicates total number of hours the
engine has been run.
Typical Panel Lights (if equipped)
Fig. 6
Lights will illuminate when the starter switch is turned to ON
position, and should be out while engine is running.
CHECK ENGINE IF LIGHTS TURN ON DURING
OPERATION.
1 Engine Oil Pressure Light
- If illuminates during
engine operation, shut down engine immediately. Check oil
level, or electrical system.
2 Battery Charging Condition Light
nates during engine operation, check electrical system.
3 Temperature Light
- If temperature light comes on
or gauge rises into the dangerous range: H = Hot Zone,
above 105° C (220° F), shut down engine immediately.
Once engine is cooled, check for low coolant level,
improper fan belt tension and clogged radiator fins.
INTERNATIONAL SYMBOLS
SHOWN ON ENGINE
Read Operating and
Maintenance Instructions
Fuel (Gasoline)
On
Off
Stop
Slow
Fast
TECHNICAL INFORMATION
Power Ratings
The power ratings for an individual engine model are initially
developed by starting with SAE (Society of Automotive
Engineers) codes J1349 and J1995 (Engine Power &
Torque Rating Procedure). Given both the wide array of
products on which our engines are placed, and the variety of
environmental issues applicable to operating the equipment,
it may be that the engine you have purchased will not
develop the rated horsepower when used in a piece of power
equipment (actual on site" power). This difference is due to
a variety of factors including, but not limited to, the following:
differences in altitude, temperature, barometric pressure,
humidity, fuel, engine lubrication, maximum governed en
gine speed, individual engine to engine variability, design of
the particular piece of power equipment, the manner in
which the engine is operated, engine run in to reduce friction
and clean out of combustion chambers, adjustments to
valves, carburetor and other factors.
Note: Engine operated at approx. 900m (3000ft) or above
sea level may require a high altitude carburetor main jet. If
erratic performance is observed, contact an Authorized
Briggs & Stratton 3/LC Service Dealer.
ENGINE SPECIFICATIONS
3 Cylinder, Liquid Cooled Gasoline Engine
THIS ENGINE IS CERTIFIED TO OPERATE ON GAS
OLINE. EXHAUST EMISSION CONTROL SYSTEM:
.
EM (Engine Modifications)
Model Series 430447, 433447
Bore
. . . . . . . . . . . . . . . . . . . . . . . . .
Stroke
. . . . . . . . . . . . . . . . . . . . . . .
Displacement
. . . . . . . . . . . . . . .
697 cc (42.5 cu. in.)
Model Series 580447, 583447, 589447
Bore
. . . . . . . . . . . . . . . . . . . . . . . . .
Stroke
. . . . . . . . . . . . . . . . . . . . . . .
Displacement
. . . . . . . . . . . . . . .
953 cc (58.1 cu. in.)
1
SAFETY SPECIFICATIONS
The safety alert symbol
information about hazards that can result in personal injury.
- If illumi
A signal word (DANGER, WARNING, or CAUTION) is
used with the alert symbol to indicate the likelihood and the
potential severity of injury. In addition, a HAZARD SYM
BOL may be used to represent the type of hazard.
DANGER
avoided, will result in death or serious injury.
WARNING
avoided, could result in death or serious injury.
CAUTION
avoided, might result in minor or moderate injury.
CAUTION,
Safety Alert
indicates a situation that could result in damage
to the engine.
Hazard Symbols
Oil
Fire
Explosion Toxic Fumes
Run
Choke
Shock
BEFORE OPERATING ENGINE
Read entire Operating & Maintenance Instruc
D
tions
.
Briggs & Stratton does not necessarily know
D
what equipment this engine will power.
Thoroughly read and understand the operating
instructions for the equipment on which this
engine is placed.
Failure to follow instructions could result in
D
serious injury or death.
The engine exhaust from this product contains chemi
cals known to the State of California to cause cancer,
birth defects, or other reproductive harm.
Briggs & Stratton does not approve or authorize the
use of these engines on 3 wheel All Terrain Vehicles
(ATVs), motor bikes/carts, aircraft products or ve
hicles intended for use in competitive events. Use of
these engines in such applications could result in
68 mm (2.68 in.)
property damage, serious injury (including paralysis),
64 mm (2.52 in.)
or even death.
72 mm (2.83 in.)
78 mm (3.07 in.)
GB
is used to identify safety
indicates a hazard which, if not
indicates a hazard which, if not
indicates a hazard which, if not
when used without the alert symbol,
Moving
Parts
Hot liquid or
Hot Surface
Steam
WARNING
WARNING
WARNING
Publicidad
Tabla de contenido
