Preface; Notices; Description; Function - Nederman FlexPAK 800 Manual Del Usuario

EN FlexPAK 800/1000 DX
9.2 Ground check measurement
9.3 Empty the collector bin
9.4 Filter package
9.5 Change control filter
9.6 Loading new software
9.6.1 Frequency converter control panel
9.6.2 Firmware and software labelling
9.6.3 Upgrading the system
9.7 Spare parts
10 Recycling
................................................................................................................................................................
10.1 Environmental information
11 Acronyms and abbreviations
1

Preface

This manual is for the correct use of this product. Read it carefully before using this product.
Replace the manual immediately if lost. For information concerning installation and maintenance,
see the Installation and Service Manual.
This product has been designed to meet the requirements of relevant EC directives. To maintain
this status, all installation, repair and maintenance work for this product is to be carried out by
qualified personnel using only Nederman original spare parts. Contact the nearest authorized
distributor or Nederman for advice on technical service and obtaining spare parts.
Nederman continuously improves its products' design and efficiency through modifications,
and reserves the right to do so without introducing these improvements to previously supplied
products. Nederman also reserve the right to, without previous notice, modify data and equipment
as well as operating and maintenance instructions.
2

Notices

This document contains important information that is presented either as a warning, caution or
note. See the following examples:
WARNING!
Warnings indicate a potential hazard to the health and safety of personnel, and how that hazard
may be avoided.
Caution! Type of risk.
Cautions indicate a potential hazard to the product but not to personnel, and how that hazard may
be avoided.
NOTE!
3

Description

3.1

Function

FlexPAK 800/1000 DX is a complete vacuum unit with a direct driven side channel fan fitted as
one unit on a steel frame and a start and control unit with an integrated 24 V transformer. The unit
is controlled by a frequency converter, has automatic start/stop, and automatic filter cleaning.

Filtration in two stages

FlexPAK 800/1000 DX filters particles in two stages. In the first stage, coarse particles are
separated away in the inlet. In the second stage, fine particles are separated away by filter bags, see
figure 9.

Automatic filter cleaning

FlexPAK 800/1000 DX uses filter cleaning by a short blast of reversed air flow with atmospheric
pressure. By the rapid opening of the Filter Cleaning Valve (FCV) located on top of the filter, a
24
All manuals and user guides at all-guides.com
..............................................................................................................
.........................................................................................................................
..........................................................................................................................................
..............................................................................................................................
...........................................................................................................................
...............................................................................................................
...............................................................................................................................................
..................................................................................................................
............................................................................................................................
Type of injury.
Notes contain other information that is important for personnel.
.......................................................................................
............................................................................................
49
50
50
50
51
51
51
51
51
52
52
53